NMC-WOLLARD 2021Truax Blvd., Eau Claire, WI 54703, Phone (715) 835-3151, Fax (715) 835-6625
M100 Tow Tractor Manual No. 46052
CHAPTER 2 MAINTENANCE
CHAPTER 2 MAINTENANCE
APRIL 15, 2012
PAGE 1
TABLE OF CONTENTS
1. SERVICING ..................................................................................................................1
1.1 CHAPTER CONTENTS ....................................................................................... 1
1.2 BOLT TIGHTENING DATA .................................................................................3
1.2 PERIODIC MAINTENANCE AND INSPECTION ...............................................4
1.3 FLUIDS AND CAPACITIES AND AMBIENT TEMPERATURE RANGES .......5
1.3.1 Preventative Maintenance Schedule ...........................................................7
1.4 DAILY SERVICE ..................................................................................................9
1.4.1 Coolant Level ................................................................................................9
1.4.2 Coolant Leaks ...............................................................................................9
1.4.3 Engine Oil Level ............................................................................................9
1.4.4 Empty Air Cleaner Dust Cup (If Conditions are Extremely Dusty) ................ 9
1.4.5 Inspect for Transmission Oil Leaks ...............................................................9
1.4.6 Lights ............................................................................................................9
1.4.7 Fuel Leaks ....................................................................................................9
1.4.8 Brake Pedal Free Play ................................................................................10
1.4.9 Tire Condition and Pressure .......................................................................10
1.4.10 Rear Axle Oil Leaks ..................................................................................10
1.4.11 Water Separator ........................................................................................10
...................................................10
1.5 EVERY 100 OPERATING HOURS - GAS MODELS ....................................... 11
1.5.1 Change Engine Oil and Oil Filter ................................................................ 11
1.5.2 Clean Crankcase Inlet Air Cleaner.............................................................. 11
1.6 EVERY 250 OPERATING HOURS OR 3 MONTHS ........................................ 11
1.6.1 Transmission Oil ......................................................................................... 11
1.6.2 Lubricate Grease Fittings ............................................................................12
1.6.3 Inspect Drive Shaft, Steering, Suspension, and Front Axle Components...12
1.6.4 Inspect Brakes ............................................................................................13
....................................................... 14
1.6.6 Instructions For Cleaning Spark Arrester/Exhaust System .........................14
1.6.7 Change Engine Oil and Oil Filter - Diesel ................................................... 15
1.6.8 Check Air Cleaner Restriction .....................................................................15
1.6.9 Replace Spark Plugs - Gas Models, Zenith ................................................16
1.6.10 Clean Fuel Pump Strainer - Perkins .........................................................16
1.6.11 Change Fuel Filter Element - Perkins .......................................................16
1.6.12 Replace Air Cleaner Element....................................................................16
1.6.13 Batteries ....................................................................................................17
1.6.14 A Sound Battery Is A Must ........................................................................19
1.6.15 Voltmeter ...................................................................................................19
1.6.16 Alternator ..................................................................................................19
1.7 EVERY 500 OPERATING HOURS OR 6 MONTHS ........................................20
To Next Page
Loading...
