NMC-WOLLARD 2021Truax Blvd., Eau Claire, WI 54703, Phone (715) 835-3151, Fax (715) 835-6625
M100 Tow Tractor Manual No. 46052
PAGE 17
CHAPTER 2 MAINTENANCE
1 SERVICING
3. Direct compressed air, DO NOT EXCEED 30 PSI, from the inside to the
outside of element by inserting air nozzle inside element. Blow loose
particles by holding nozzle at least 6" from element.
4. Clean inside of canister with a damp, lint-free cloth. Also clean dust cap
5. Remove air cleaner inlet cap. Wash cap with water and wipe dry with a
clean cloth.
6.
cap. Secure dust cap to canister by tightening retaining strap.
7. Install air cleaner inlet cap.
8. Check and tighten all air induction connections before resuming
operations.
1.6.13 Batteries
servicing safety precautions:
• Sulfuric battery acid is poisonous. Avoid breathing battery fumes.
• Battery acid is strong enough to burn skin and cause blindness if splashed
into the eyes. Protect eyes and skin from contact. In the event of contact
with battery acid, immediately rinse in large amounts of water. Obtain
medical care if the eyes are burned.
•
• Never check battery charge by placing a metal object across the battery
posts. A spark will occur and cause possible explosion. Use a voltmeter or
hydrometer.
Maintenance
The 12-volt battery supplied with your loader will provide long service if given
proper care. Clean and inspect your battery every 3-4 months.
• The battery requires little maintenance.
• If the electric system has a defect, i.e., regulator damage, compensate for
increased water consumption of battery.
• Unscrew the sealing caps and replenish distilled water until battery acid
level is 3/8” above the lead plates. Screw on caps hand-tight.
AUGUST 15, 2011
To Next Page
Loading...
