NMC-WOLLARD 2021Truax Blvd., Eau Claire, WI 54703, Phone (715) 835-3151, Fax (715) 835-6625
M100 Tow Tractor Manual No. 46052
PAGE 9
CHAPTER 2 MAINTENANCE
1 SERVICING
1.4 DAILY SERVICE
1.4.1 Coolant Level
Raise engine hood and visually check level of coolant in coolant reservoir.
glycol-base engine coolant (Fed. Spec. A-A-870).
1.4.2 Coolant Leaks
After tractor has been parked overnight, check ground under engine for
leaked coolant (green-colored). If found, try to locate exact source of the leak.
If source is a loose hose, tighten hose clamp or replace hose if necessary. If
radiator or water pump is leaking, report condition to a supervisor.
1.4.3 Engine Oil Level
oil level. If low, add engine oil as required. Use correct viscosity grade for the
temperature range in which the tractor will be operating. See Section 1.3
1.4.4 Empty Air Cleaner Dust Cup (If Conditions are Extremely Dusty)
Remove retaining strap securing dust cup to canister. Remove dust cup.
element. Clean out dust from canister and dust cup with a damp, lint-free
cloth. Install element and dust cup. Replace element if necessary.
NOTICE!
1.4.5 Inspect for Transmission Oil Leaks
After tractor has been parked overnight, check ground under tractor for
and report condition to your supervisor.
1.4.6 Lights
Check operation of all tractor lights. Replace any burned-out lights.
1.4.7 Fuel Leaks
Raise engine cover and inspect fuel line connections for leaks. Be sure fuel
lines are securely fastened by retaining clips.
APRIL 15, 2012
To Next Page
Loading...
