Omron MicroHAWK - Page 296

Omron MicroHAWK

378 pages

Save Page as PDF

To Next Page

To Next Page

To Previous Page

To Previous Page

Loading...

11-28 MicroHAWK Engine Integration Guide

Set License

Table of Contents

Default Chapter3
- Table of Contents3
Chapter 1 Quick Start12
- Microhawk Engine and Weblink Quick Start12
- Step 1 Check Hardware and Connect the System12
- Step 2 Mount and Position the Reader13
- Step 4 Connect to Weblink15
- Step 5 Explore the Start View16
- Step 6 Create a New Setup or Load an Existing Setup17
- Step 7 Explore the Setup View18
- Step 8 Configure Read Cycle Settings19
- Step 9 Configure Acquire Settings21
- Step 10 Configure Symbology Settings23
- Step 11 Format Output and Configure Match String24
- Step 12 Configure Output 1, 2, and 3 Settings25
- Step 13 Run the Application26
- Microhawk Engine and ESP Software Quick Start27
- Step 1 Check Hardware and Connect the System27
- Step 2 Mount and Position the Reader28
- Step 3 Install ESP29
- Step 4 Select Model30
- Step 5 Connect31
- Step 6 Locate the Symbol in the Field of View32
- Step 7 Calibrate33
- Step 8 Test Read Rate34
- Step 9 Configure the Reader in ESP35
- Step 10 Save Configuration in ESP36
- Microhawk Engine and Autovision Quick Start37
- Autovision Overview38
- Select a Device49
- Adjust Camera Settings50
- Edit the Job52
- Run the Job53
- Save the Job54
- Additional Notes CPU Idle States (C-States)55
- Microhawk Part Number Structure56
Chapter 2 Using ESP58
- EZ Mode58
- Application Mode59
- Menu Toolbar60
- View70
- Navigating in ESP71
- Send/Receive Options72
Chapter 3 Integration76
- Microhawk Engine Hardware at a Glance76
- Mounting Specifications77
- Optical Requirements78
- Viewing Port Specifications79
- Expansion Connector (FPC)80
Chapter 4 Communications81
- Communications by ESP82
- Communications Serial Commands83
- Network Interfaces84
- Host Port Connections85
- Host Port Protocol86
- ACK/NAK Options87
- Polling Mode Options88
- Ethernet89
- Response Timeout95
- LRC (Longitudinal Redundancy Check) Status96
- Protocol Configuration Examples97
- Preamble98
- Postamble99
- USB Hid/Keyboard100
- Ethernet/Ip Byte Swapping Enabled105
- USB Mass Storage Driver106
- Entering ASCII Characters as Hex Values107
Chapter 5 Calibration109
- Calibration Serial Commands110
- Calibration Overview110
- Calibration Options111
- Calibration by ESP116
- Initiating Calibration118
- Additional Notes about Calibration119
Chapter 6 Read Cycle122
- Read Cycle by ESP122
- Read Cycle Serial Commands123
- Read Cycle Setup124
- Multisymbol125
- Trigger Mode and Filter Duration126
- External Trigger Polarity131
- Serial Trigger132
  - Start Trigger Character (Non-Delimited)133
  - Stop Trigger Character (Non-Delimited)134
- End of Read Cycle135
- Capture Mode137
- Capture Timing142
- Image Processing Timeout144
- Image Storage145
- Minimum Good Reads147
Chapter 7 Symbologies150
- Symbologies by ESP150
- Symbologies Serial Commands151
- Data Matrix152
- Aztec154
- QR Code155
- Micro QR Code156
- Code 39157
- Code 128/EAN 128160
- Bc412163
- Interleaved 2 of 5164
- Code 93167
- Codabar168
- Upc/Ean171
- Pharmacode175
- Postal Symbologies177
- GS1 Databar182
- Pdf417184
- Micropdf417185
- Composite186
- Dotcode187
Chapter 8 I/O Parameters190
- I/O Parameters by ESP190
- I/O Parameters Serial Commands191
- Symbol Data Output192
- No-Read Message196
- Read Duration Output197
- Output Indicators198
- LED Configuration202
- Serial Verification203
- Setup Button204
- Setup Button Modes206
- Configurable Output 1208
- Trend Analysis Output 1211
- ISO/IEC 16022 Symbol Quality Output 1214
- Diagnostic Output 1217
- Configurable Output 2218
- Trend Analysis Output 2218
- ISO/IEC 16022 Symbol Quality Output 2218
- Diagnostic Output 2218
- Configurable Output 3219
- Trend Analysis Output 3219
- ISO/IEC 16022 Symbol Quality Output 3219
- Diagnostic Output 3219
- Power-On/Reset Counts220
- Time Since Reset221
- Service Message222
  - User-Assigned Name223
- Frame Information224
- Image Output225
- Database Identifier Output228
- Quality Output229
- EZ Trax Output230
- Image Push to Host233
- Image Push to Host Detailed Setup235
Chapter 9 Symbol Quality240
- Symbol Quality by ESP240
- Symbol Quality Serial Commands241
- Overview of Symbol Quality242
- Symbol Quality Separator/Data Matrix Output Mode246
- ISO/IEC 16022 Symbol Quality Output248
- ISO/IEC 16022 Symbol Quality Output by ESP250
- Omron Microscan Symbol Quality Output251
- Omron Microscan Symbol Quality Output by ESP254
Chapter 10 Matchcode256
- Matchcode by ESP256
- Matchcode Serial Commands257
- Overview of Matchcode258
- Matchcode Type259
- Sequence Step Interval264
- Match Replace265
- Mismatch Replace266
- New Master Pin267
Chapter 11 Camera and IP Setup270
- Camera and IP Setup by ESP270
- Camera and IP Setup Serial Commands271
- Video272
- Evaluation273
- Calibration276
- Window of Interest277
- Configuration Database281
- Dynamic Setup282
- Pixel Binning283
- Camera Settings284
- White Balance Settings285
- Color Filter286
- Focal Distance287
- Illumination Brightness288
- Morphological Pre-Processing289
- Morphological Operation and Operator Size290
- Damaged Symbol293
- Linear Security Level294
- Set License295
Chapter 12 Configuration Database298
- Configuration Database Serial Commands298
Chapter 13 Terminal317
- Find317
- Send318
- Macros319
- Terminal Menus320
Chapter 14 Utilities322
- Operational Commands322
- Read Rate324
- Counters326
- Device Control328
- Differences from Default329
- Master Database330
- Firmware336
- Default/Reset/Save339
- Reader Status Requests341
- Other Operational Serial Commands343
Chapter 15 Output Format348
- Output Format Serial Commands348
- Output Format Status349
- Format Assign350
- Format Extract351
- Format Insert353
- Output Filter Configuration355
- Number of Filters360
- Appendices361
Appendix A General Specifications362
Appendix B Electrical Specifications367
Appendix C Quantum Efficiency Specifications369
Appendix D Serial Commands370
Appendix C Serial Commands370
Appendix E Communications Protocol372
Appendix D Communications Protocol373
Appendix F ASCII Table373
Appendix E ASCII Table373
Appendix G Glossary of Terms374
Appendix F Glossary of Terms374

Related product manuals

Preview: Omron MicroHAWK ID-40

Omron MicroHAWK ID-40

Preview: Omron MicroHAWK V320-F

Omron MicroHAWK V320-F

Preview: Omron MicroHAWK F320-F

Omron MicroHAWK F320-F

Preview: Omron ACCURAX G5

Omron ACCURAX G5

Preview: Omron STC-MBS500POE

Omron STC-MBS500POE

Preview: Omron STC-MBE132POE

Omron STC-MBE132POE

Omron STC-MCS500POE

Preview: Omron STC-MBS122BPOE

Omron STC-MBS122BPOE