Omron MicroHAWK

To Next Page

To Previous Page

4-10 MicroHAWK Engine Integration Guide

Ethernet

Subnet

This is the subnet of the reader when it is in Static IP Address Mode.

Gateway

This is the gateway IP address of the reader when it is in Static IP Address Mode.

Main Page

Default Chapter3
- Table of Contents3
Chapter 1 Quick Start12
- Microhawk Engine and Weblink Quick Start12
- Step 1 Check Hardware and Connect the System12
- Step 2 Mount and Position the Reader13
- Step 4 Connect to Weblink15
- Step 5 Explore the Start View16
- Step 6 Create a New Setup or Load an Existing Setup17
- Step 7 Explore the Setup View18
- Step 8 Configure Read Cycle Settings19
- Step 9 Configure Acquire Settings21
- Step 10 Configure Symbology Settings23
- Step 11 Format Output and Configure Match String24
- Step 12 Configure Output 1, 2, and 3 Settings25
- Step 13 Run the Application26
- Microhawk Engine and ESP Software Quick Start27
- Step 1 Check Hardware and Connect the System27
- Step 2 Mount and Position the Reader28
- Step 3 Install ESP29
- Step 4 Select Model30
- Step 5 Connect31
- Step 6 Locate the Symbol in the Field of View32
- Step 7 Calibrate33
- Step 8 Test Read Rate34
- Step 9 Configure the Reader in ESP35
- Step 10 Save Configuration in ESP36
- Microhawk Engine and Autovision Quick Start37
- Autovision Overview38
- Select a Device49
- Adjust Camera Settings50
- Edit the Job52
- Run the Job53
- Save the Job54
- Additional Notes CPU Idle States (C-States)55
- Microhawk Part Number Structure56
Chapter 2 Using ESP58
- EZ Mode58
- Application Mode59
- Menu Toolbar60
- View70
- Navigating in ESP71
- Send/Receive Options72
Chapter 3 Integration76
- Microhawk Engine Hardware at a Glance76
- Mounting Specifications77
- Optical Requirements78
- Viewing Port Specifications79
- Expansion Connector (FPC)80
Chapter 4 Communications81
- Communications by ESP82
- Communications Serial Commands83
- Network Interfaces84
- Host Port Connections85
- Host Port Protocol86
- ACK/NAK Options87
- Polling Mode Options88
- Ethernet89
- Response Timeout95
- LRC (Longitudinal Redundancy Check) Status96
- Protocol Configuration Examples97
- Preamble98
- Postamble99
- USB Hid/Keyboard100
- Ethernet/Ip Byte Swapping Enabled105
- USB Mass Storage Driver106
- Entering ASCII Characters as Hex Values107
Chapter 5 Calibration109
- Calibration Serial Commands110
- Calibration Overview110
- Calibration Options111
- Calibration by ESP116
- Initiating Calibration118
- Additional Notes about Calibration119
Chapter 6 Read Cycle122
- Read Cycle by ESP122
- Read Cycle Serial Commands123
- Read Cycle Setup124
- Multisymbol125
- Trigger Mode and Filter Duration126
- External Trigger Polarity131
- Serial Trigger132
  - Start Trigger Character (Non-Delimited)133
  - Stop Trigger Character (Non-Delimited)134
- End of Read Cycle135
- Capture Mode137
- Capture Timing142
- Image Processing Timeout144
- Image Storage145
- Minimum Good Reads147
Chapter 7 Symbologies150
- Symbologies by ESP150
- Symbologies Serial Commands151
- Data Matrix152
- Aztec154
- QR Code155
- Micro QR Code156
- Code 39157
- Code 128/EAN 128160
- Bc412163
- Interleaved 2 of 5164
- Code 93167
- Codabar168
- Upc/Ean171
- Pharmacode175
- Postal Symbologies177
- GS1 Databar182
- Pdf417184
- Micropdf417185
- Composite186
- Dotcode187
Chapter 8 I/O Parameters190
- I/O Parameters by ESP190
- I/O Parameters Serial Commands191
- Symbol Data Output192
- No-Read Message196
- Read Duration Output197
- Output Indicators198
- LED Configuration202
- Serial Verification203
- Setup Button204
- Setup Button Modes206
- Configurable Output 1208
- Trend Analysis Output 1211
- ISO/IEC 16022 Symbol Quality Output 1214
- Diagnostic Output 1217
- Configurable Output 2218
- Trend Analysis Output 2218
- ISO/IEC 16022 Symbol Quality Output 2218
- Diagnostic Output 2218
- Configurable Output 3219
- Trend Analysis Output 3219
- ISO/IEC 16022 Symbol Quality Output 3219
- Diagnostic Output 3219
- Power-On/Reset Counts220
- Time Since Reset221
- Service Message222
  - User-Assigned Name223
- Frame Information224
- Image Output225
- Database Identifier Output228
- Quality Output229
- EZ Trax Output230
- Image Push to Host233
- Image Push to Host Detailed Setup235
Chapter 9 Symbol Quality240
- Symbol Quality by ESP240
- Symbol Quality Serial Commands241
- Overview of Symbol Quality242
- Symbol Quality Separator/Data Matrix Output Mode246
- ISO/IEC 16022 Symbol Quality Output248
- ISO/IEC 16022 Symbol Quality Output by ESP250
- Omron Microscan Symbol Quality Output251
- Omron Microscan Symbol Quality Output by ESP254
Chapter 10 Matchcode256
- Matchcode by ESP256
- Matchcode Serial Commands257
- Overview of Matchcode258
- Matchcode Type259
- Sequence Step Interval264
- Match Replace265
- Mismatch Replace266
- New Master Pin267
Chapter 11 Camera and IP Setup270
- Camera and IP Setup by ESP270
- Camera and IP Setup Serial Commands271
- Video272
- Evaluation273
- Calibration276
- Window of Interest277
- Configuration Database281
- Dynamic Setup282
- Pixel Binning283
- Camera Settings284
- White Balance Settings285
- Color Filter286
- Focal Distance287
- Illumination Brightness288
- Morphological Pre-Processing289
- Morphological Operation and Operator Size290
- Damaged Symbol293
- Linear Security Level294
- Set License295
Chapter 12 Configuration Database298
- Configuration Database Serial Commands298
Chapter 13 Terminal317
- Find317
- Send318
- Macros319
- Terminal Menus320
Chapter 14 Utilities322
- Operational Commands322
- Read Rate324
- Counters326
- Device Control328
- Differences from Default329
- Master Database330
- Firmware336
- Default/Reset/Save339
- Reader Status Requests341
- Other Operational Serial Commands343
Chapter 15 Output Format348
- Output Format Serial Commands348
- Output Format Status349
- Format Assign350
- Format Extract351
- Format Insert353
- Output Filter Configuration355
- Number of Filters360
- Appendices361
Appendix A General Specifications362
Appendix B Electrical Specifications367
Appendix C Quantum Efficiency Specifications369
Appendix D Serial Commands370
Appendix C Serial Commands370
Appendix E Communications Protocol372
Appendix D Communications Protocol373
Appendix F ASCII Table373
Appendix E ASCII Table373
Appendix G Glossary of Terms374
Appendix F Glossary of Terms374

Omron MicroHAWK - Page 90

Table of Contents

Related product manuals