Multi Pro 1750
Page 5 − 1
Electrical System
Chapter 5
Electrical System
Table of Contents
GENERAL INFORMATION 2.....................
Operator Manual 2............................
Electrical Drawings 2..........................
Toro Electronic Controller (TEC) 2..............
CAN−bus Communications 2...................
SPECIAL TOOLS 3.............................
Traction Speed Sensor Test Harness 5..........
Flow Meter Sensor Test Harness 6..............
INFOCENTER DISPLAY 7.......................
InfoCenter Display Screens 8..................
Splash Screen 9..............................
Main Information Screen 10....................
Application Record Screens 11.................
Spray Tank Volume Screen 12..................
Main Menu Screen 13.........................
Calibration Screen 13.........................
Settings Screen 14............................
Service Screens 16...........................
Diagnostics Screen 17.........................
About Screen 18..............................
TROUBLESHOOTING 20........................
Operator Advisory Screen 20...................
Operator Advisories 21........................
Using the InfoCenter Display for
Troubleshooting 22..........................
Fault Codes 24...............................
Starting Problems 26..........................
General Run Problems 27.....................
ELECTRICAL SYSTEM QUICK CHECKS 28.......
Battery Test (Open Circuit Test) 28..............
Charging System Test 28......................
Check Operation of Interlock System 28.........
COMPONENT TESTING 30......................
Fusible Link Harness 30.......................
Fuses 31....................................
Toro Electronic Controller (TEC) 32.............
Ignition Switch 34.............................
Operator Seat Switch 35.......................
Parking Brake Switch 36.......................
Clutch Switch 37..............................
Throttle Home Switch 37.......................
Service Brake Switch 37.......................
Neutral Switch 38.............................
Traction Speed Sensor 39.....................
Traction Speed Sensor 40.....................
Master Boom (Spray Enable) Switch 41..........
Boom Spray Switches
(Serial Number Below 315000000) 42.........
Boom Spray Switches
(Serial Number Above 315000000) 43.........
Spray Pump Switch 44........................
Agitation Switch 44............................
Application Rate (Spray Pressure) Switch 45.....
Supervisor Key Switch 46......................
Boom Lift Switches 47.........................
Speed/Throttle Lock Switch 48.................
Headlight Switch 49...........................
Brake Pressure Switch 50......................
Relays with Four (4) Terminals 51...............
Relays with Five (5) Terminals 52...............
Speed/Throttle Lock Coil 54....................
Pump Drive Electric Clutch 55..................
Spray System Valve Actuators
(ARAG − Serial Numbers Below 315000000) 56.
Spray System Valve Actuators
(KZ − Serial Numbers Above 315000000) 57...
Hydraulic Solenoid Valve Coils 58...............
CAN−bus Terminator Resistors 59..............
Diode Assemblies 59..........................
Flow Meter Sensor 60.........................
Tank Clean Rinse Kit Switch (Optional) 61.......
Foam Marker Kit ON/OFF Switch (Optional) 62...
Foam Marker Kit Control Switch (Optional) 63....
Electric Hose Reel Kit Switch (Optional) 64.......
SERVICE AND REPAIRS 65.....................
Battery Storage 65............................
Battery Care 65...............................
Battery Service 66............................
Flow Meter Sensor 69.........................
Headlights 70................................
Pump Drive Electric Clutch 71..................
Electrical
System