Home
Invacare
Wheelchair
Kite
Page 60
Invacare Kite - Page 60
144 pages
Manual
Save Page as PDF
To Next Page
To Next Page
To Previous Page
To Previous Page
Loading...
SERVIC
E MANUAL
Invacare
®
-
Kit
e
60
Uninstal
ling the hea
dlight bra
cket:
•
Loosen both Tor
x s
crews (2).
•
Rem
ove the headlight bracket (
1).
•
Replace the brack
et.
Install
ing the head
light brac
ket:
•
Assem
ble all parts again in reverse or
der.
•
Tighten the sc
rews hand
-
tight.
•
Check
all vehicle functions.
59
61
Table of Contents
Main Page
Default Chapter
5
Table of Contents
5
1 Introduction
9
General Information
9
Notes on Shipping
9
Definition and Representation of Information and Safety Information in this Manual
10
Hazard Symbols and Symbols Used
11
Images in this Manual
12
2 Safety and Fitting Instructions
13
Before any Inspection or Repair Work
13
Personal Safety Equipment
13
General Safety Information and Information about Fitting / Removal
13
3 Tightening Torques
15
4 Layout of Components and Componentry
16
Overview
16
Overview of the Electronic Modules (ACS 2 System)
17
ACS 2 70 / ACS 2 70L / ACS 2 90L Electronic Module
19
ACS 2 90LG Electronic Module
19
ACT Actuator Module
19
ACT 2 Actuator Module
19
ACT 4 Actuator Module
20
Lighting PCB
20
5 Service Plan (1X Annually)
21
6 Operational Faults
23
Drive Fault Diagnosis
23
ACS2 Remotes: Error Codes and Diagnostic Codes
25
7 Test Procedures
26
Testing the Motor
26
Testing the Electro-Mechanical Parking Brake
27
Checking an Actuator
29
8 Repair Work
30
Covers
30
Rear Cover
30
Middle Cover
31
Side Cover
32
Front Cover
33
Replacing a Front Splash Guard
34
Replacing the Splash Guard
35
Electronic Modules
36
Replacing the Power Module
36
Replacing the Actuator Module
38
Replacing the G-Trac Sensor
39
Replacing the Lighting Circuit Board
40
Replace Remote
41
Drive Program Selection after Component Replacement
42
Profile Selection with Remote REM a or REM B
42
Profile Selection with Remote REM 550
43
Updating the Driving Program
44
Batteries
45
Removing the Batteries
45
Correct Handling of Damaged Batteries
48
Checking and Replacing the Main Fuse
49
Checking the Cables
51
Lighting System
52
Replacing Front Headlight Completely (LED Lighting Unit)
52
Replacing the Front Bulb Holder (LED Lighting Unit)
54
Replacing the Rear Light Completely (LED Lighting Unit)
55
Replacing Light Bulbs in the Front (Conventional Lighting System)
56
Replacing the Head Lamps Completely (Conventional Lighting System)
57
Replacing the Headlight Bracket (Conventional Lighting System)
59
Replacing the Rear Bulb (Conventional Lighting Unit)
61
Replacing the Complete Tail Light Assembly (Conventional Lighting System)
62
Replacing the Tail Light Bracket (Conventional Lighting System)
63
Front Wheels
64
Repairing a Flat Tire in the Front
64
Replacing the Steering Head Bearings on the Steering Wheels
64
Changing a Front Wheel (Normal Front Wheel)
67
Changing a Front Wheel (Suspended Front Wheel)
69
Drive Wheels
70
Replacing the Drive Wheel
70
Replacing a Tyre or Inner Tube
71
Replacing Puncture-Protected Tyres
71
Replacing Puncture-Proof Tyres
73
Replacing the Drive Wheel Hub
74
Drive Unit
75
Replacing the Motor/Transmission Unit
75
Replacing or Rotating the Motor / Gearbox Unit Sealing Ring
77
Replacing the Motor / Gearbox Coupling
78
Replacing the Carbon Brushes
80
Replacing the Rubber Shock Absorbers
82
Replacing the Tube Frame
84
Replacing the Double Bearing of the Dual Swing Technology (D.S.T.)
86
Replacing the Battery Boxes
88
Seat System
89
Replacing the Tilt Actuator
89
Replacing the Tilt Module
91
Replacing the Lifter / Tilt Module
93
Backrest Unit
97
Replacing the Standard Backrest
97
Replacing a Standard Backrest with Quick Release
99
Replacing a Flex2 Backrest
100
Adjusting Backrest Former
101
Seat System Modulite
102
Replacing the Tilt Actuator
102
Replacing the Lifter Actuator
103
Replacing the Lifter / Seat Angle Adjustment Module
104
Replacing the Backrest Actuator
107
Backrest Modulite
108
Replacing the Standard Backrest
108
Replacing the Backrest Mounting Bracket
109
Replacing the Backrest Mounting Bracket for SB 53
110
Adjusting the Seat Width/ Backrest Width (Modulite)
111
Adjusting the Seat Width
111
Adjusting the Backrest Width
113
Adjusting the Flex3 Backrest
115
9 Installing Accessories
116
Replacing the Holding Strap
116
Replacing Seat Belts (Modulite Seat)
117
Installation on the Backrest Mounting Bracket (Simple Backrest)
117
Installation on the Backrest Mounting Bracket (Adjustable Seat)
118
Installation on the Seat Frame Profile (Adjustable Seat)
119
Operating Hours Counter
120
Replacing the Operating Hours Counter
120
Replacing the Connecting Cable of the Operating Hours Counter
122
Luggage Carrier
124
Further Accessories
125
10 Adjusting the Seating Position
126
Adjusting the Lower Leg Length and Seat Depth
127
Adjusting the Lower Leg Length
127
Adjusting the Seat Depth
127
Adjusting the Seat Angle
128
12° Adjusting the Seat Angle with Standard Seat or Flex2 Seat
129
20° Adjusting the Seat Angle Flex2 Seat or Modulite Seat
131
Adjusting the Center of Gravity of the Seat
133
Standard Seat
137
Flex2 Seat
138
Modulite Seat
141
Adjustable Seats
143
Simple Seat
144
Other manuals for Invacare Kite
User Manual
160 pages
Related product manuals
Invacare Bora
134 pages
Invacare TDX SP
184 pages
Invacare Mirage
121 pages
Invacare Action 4
36 pages
Invacare Tracer IV
52 pages
Invacare Pronto M51
96 pages
Invacare Pronto M41
96 pages
Invacare TRACER EX2
64 pages
Invacare Pro Series
56 pages
Invacare Lightweight
64 pages
Invacare 9000 series
60 pages
Invacare Action 3 Junior
64 pages
To Next Page
Loading...
