Somat eDAQlite - Page 88

228 pages

Save Page as PDF

To Next Page

To Next Page

To Previous Page

To Previous Page

Loading...

Somat eDAQ

lite

88

I2773-4.4 en

HBM: public

Table of Contents

Default Chapter3
- Table of Contents3
Safety Information13
1 Getting Started17
- Overview17
- Edaq Lite Layers17
- Equipment17
- Provided Equipment17
- Support Equipment18
- Setting up the System19
- Installing Somat Test Control Environment (TCE)19
- Getting Familiar with the Edaq Lite System19
- Setting up the Edaq Lite20
- Test Process21
2 Using the Edaq Lite23
- Edaq Lite Base System23
- Status Leds23
- Edaq Lite Layers24
- Updating Firmware27
- Communications28
- Communications Methods28
- Changing the Edaq Lite IP Address and Host Name29
- Power Considerations30
- Input Power Voltage31
- Battery Power32
- Remote Power32
- Power Save Mode33
- Powering an Edaq Lite from a Vehicle34
- Data Storage37
- Data Formats37
- Data Storage Options38
- Networking Edaq Lite /Edaq Systems39
- Hardwired Network39
- Wireless Network40
3 Test Control Environment (TCE)41
- TCE User Interface41
- Setup Windows41
- Pull down Menus44
- Toolbar48
- Status Bar49
- TCE Preferences49
- Communications50
- General50
- FCS Specific52
- Remote Test Run Control54
- Scope and Spectrum Display56
- Run-Time Display56
- Group DVM Display57
- Auto Range Options57
4 Using TCE59
- Defining a Test59
- Adding a Network Node59
- Configuring the Hardware60
- Creating Channels and Datamodes61
- Using Existing Setup Definitions62
- Calibrating Input Channels63
- Calibration Modes63
- Calibration Control67
- Calibration Specifications68
- Running a Test68
- Initializing a Test69
- Prerun Options69
- Previewing a Test Run70
- Starting a Test Run70
- Using Interactive Triggers71
- Stopping a Test Run71
- Ending a Test71
- Monitoring Test Status71
- Viewing Channel Displays72
- Displays Overview73
- Common Display Options74
- DVM75
- Scope Plot77
- Spectrum Plot78
- Digital Readout79
- Bar Chart80
- Strip Chart81
- Uploading Test Data82
- Uploading SIE Data Files82
- Uploading SIF Data Files82
- Extracting Data from SIE or SIF Files83
- Using Remote Control Operation85
- Networking Edaq Lite /Edaq Systems86
- Using Remote Control with a Network87
5 Edaqlite Hardware89
- ELCPU (Base Processor)89
- ELCPU Available Inputs89
- ELCPU Configuration Options89
- ELCOM (Vehicle Network Communications Layer)91
- ELCOM Available Inputs91
- ELCOM Configuration Options91
- ELDIO (Digital Input/Output Layer)91
- ELDIO Available Inputs and Outputs91
- ELDIO Configuration Options92
- ELBRG (Bridge Layer)94
- ELHLS (High Level Analog Layer)95
- ELNTB (Non-Isolated Thermocouple Layer)95
- EGPS-5HZ (Somat GPS Receiver)96
- Available Inputs97
- Configuration Options97
- EGPS-200 (Precision GPS Module)97
- Available Inputs98
- Configuration Options98
- Vehicle Bus Module99
- VBM Available Inputs99
- VBM Configuration Options99
- Importing A2L Files100
- SMART Modules101
- Network Camera Devices102
- Network Camera Available Inputs102
- Network Camera Configuration102
- Network Camera Troubleshooting105
6 Input Channels107
- Common Input Channel Parameters107
- Desired Measurement107
- Output Sample Rate108
- Full-Scale Values108
- Output Data Type108
- Calibration Table108
- Prerun Rezero109
- Display Control110
- Digital Input Channels110
- Digital Input110
- Pulse Counter111
- Analog Input Channels113
- Bridge113
- Simultaneous High Level116
- SMART Module Input Channels118
- SMSTRB4 (Strain SMART Module)118
- SMITC (Thermocouple SMART Module)121
- Temperature Input Channels121
- Thermocouple121
- Bus-Oriented Input Channels121
- Common Bus Channel Parameters122
- Vehicle Bus Message Channel123
- Network Camera Input Channel124
- Simulation Input Channels125
- Simulation File125
- Simulation Function Generator126
- Simulation Message127
7 Computed Channels129
- Common Computed Channel Parameters129
- Arithmetic Computed Channels130
- Desk Calculator130
- Engineering Scaler133
- Integer Scaler133
- Integrator134
- Pulse Counter136
- Directional Velocity137
- State Mapper138
- Statistical Analysis139
- Damage Equivalent Load141
- Fatigue Damage142
- Triggering Computed Channels145
- Interactive Trigger145
- Trigger Generator145
- Timed Trigger146
- Triggered Zero Suppression147
- Bitmap Trigger148
- Test Run Stopper149
- Power Saver149
- Time, Sample Rate and Filter Computed Channels150
- Time Channel150
- Time Base Shifter151
- Down Sampler151
- Up Sampler152
- Smoothing Filter153
- Digital Filter154
- Tracking Computed Channels155
- Max Track155
- Min Track155
- Range Track156
- Anomaly Detect157
- Triggered Latch158
- Over Range Detector159
- Valid Data Gate160
8 Datamodes161
- Datamode™ Memory Consumption161
- Common Datamode™ Parameters161
- Sequential Datamodes163
- Time History163
- Burst History164
- Event Slice167
- Message Logger168
- Peak Valley168
- Peak Valley Slice169
- Histogram Datamodes170
- Common Histogram Parameters170
- Peak Valley Matrix171
- Rainflow171
- Time at Level (One Dimensional)172
- Time at Level (Multidimensional)172
- Digital Output173
9 Edaq Lite Web Interface175
- Main Page175
- System Tab175
- System Setup176
- System Status177
- System Maintenance177
- Hardware Tab178
- Hardware Table178
- Manage Network Cameras179
- Select Storage Device180
- Channels Tab180
- Test Tab180
- Data Tab181
- SIE Test Data181
- SIF Test Data182
- Custom Tab182
- Help Tab182
10 Troubleshooting183
- Troubleshooting Procedure183
- Known Problems184
- Edaq Lite Flags184
- Status Flags184
- Error Flags186
- Corrupt SIF File Data Recovery187
- Tips on Eliminating Edaq Lite Overflow Errors188
11 Data Types191
12 Cable Pinouts195
- ELCPU (Main Processor)195
- Communications Cable195
- Power Cable197
- ELCOM (Vehicle Communications Layer)197
- ELHLS (High Level Analog Layer)198
- ELBRG (Bridge Layer)198
- ELDIO (Digital I/O Layer)199
- Vehicle Bus Modules (VBM)199
- Transducer Cable for VPW Interface199
- Transducer Cable for J1708 Interface200
- Transducer Cable for CAN/SWC Interface200
- Transducer Cable for ISO9141/KW2000 Interface201
- Transducer Cable for MIL1553 Interface201
13 Device Wiring203
- ELDIO (Digital I/O Layer)203
- ELDIO Digital Input203
- ELDIO Digital Output204
- ELHLS (High Level Analog Layer)205
- ELHLS Analog Input205
- SMSTRB4 (Strain SMART Module)205
- ELBRG (Bridge Layer)206
- ELBRG Bridge Transducers206
- ELBRG Analog Input208
14 Data Synchronization209
- Data Synchronization Characterization Method209
- Analog Channel Synchronization209
- ELHLS and ELBRG Channel Synchronization210
- Digital Channel Synchronization211
- Resampled Channel Synchronization211
- Bus-Oriented Channel Synchronization212
- Thermocouple Channel Synchronization212
- Networked Edaq Lite /Edaq System Synchronization212
- Hardwired Network Synchronization212
- Wireless Network Synchronization212
15 Digital Filtering213
- Signal Aliasing213
- Digital Filter Characteristics213
- ELHLS and ELBRG Digital Filters214
16 Xth-Percentile Benchmark Tests219
17 Data Processing Algorithms221
- Peak Valley Processing Algorithm221
- Rainflow Cycle Counting Algorithm221
18 Cable Resistances223
19 CE Compliance225
- Edaq Lite Hardware225
- Cables226