TROUBLE ANALYSIS
9-1
E
TRBL
ANLS
TROUBLE ANALYSIS
NOTE:
The following items should be checked before the "TROUBLE ANALYSIS CHART" is con-
sulted.
1. The battery is charged and its specific gravity is within specification.
2. There are no incorrect wiring connections.
3. Wiring connections are properly secured and are not rusty.
4. The lanyard is installed onto the engine stop switch.
5. The shift position is in neutral.
6. Fuel is reaching the carburetor/vapor separator.
7. The rigging and engine setting are correct.
8. The engine is free from any "Hull problem".
TROUBLE ANALYSIS CHART
Trouble mode Check elements
ENGINE WILL NOT START
ROUGH IDLING
ENGINE STALLS
POOR DECELERATION
ENGINE WILL NOT STOP
POOR PERFORMANCE
OVERHEATING
LOOSE STEERING
LOOSE TILT HOLDING
TILT MOTOR WILL NOT RUN
SHIFTING DIFFICULT
IRREGULAR WARNING INDICATION
POOR BATTERY CHARGING
Relative part
Reference
chapter
FUEL SYSTEM
:: : Fuel hose 4
:: Fuel joint 4
:: : Fuel filter 4
:: Fuel pump 4
:: : Carburetor 4
:: • Idle speed 3
: • Throttle valve synchronization 3
:: : • Pilot screw 3
:: : • Choke link 3
:: • Fast idle 3
:: •Dash pot 3
:: • Unloader 3
To Next Page
