MAINTENANCE INTERVAL CHART
3-1
E
CHK
ADJ
MAINTENANCE INTERVAL CHART
Use the following chart as a guide to general maintenance intervals.
Dependant on operating conditions, adjust the maintenance intervals accordingly.
(*1)
If Yamaha portable fuel tank is used.
(*2)
Do not adjust the carburetor when it is operating properly.
Item Remarks
Initial Every
Refer to
page
10 hours
(Break-in)
50 hours
(3 months)
100 hours
(6 months)
200 hours
(1 year)
TOP COWLING
Top cowling fit Check ::—
FUEL SYSTEM
Fuel line Check : 3-2
Fuel filter Check/clean :: : 3-3
Fuel tank Cleaning
(*1)
: —
POWER UNIT
Engine oil Check/replace ::3-12
Oil filter Replace : 3-12
Timing belt Check/replace : 3-17
Valve clearance Check/adjust ::3-14
Thermostat Check/replace : 5-38
Water leakage Check :: : —
Motor exterior Check :: —
Exhaust leakage Check :: : —
Cooling water passage Check :: —
CONTROL SYSTEM
Throttle cable Check/adjust : 3-4
Shift cable Check/adjust : 3-3
Engine idling speed Check/adjust ::3-5
Carburetor
(*2)
Check/adjust : 3-9
POWER TRIM AND TILT UNIT
Power trim and tilt Check :: : 3-18
LOWER UNIT
Gear oil Change ::3-19
Lower unit leakage Check : 3-20
Propeller Check :: 6-3
GENERAL
Anodes Check/replace :: 3-21
Battery Check/charge : every month 3-21
Spark plugs Clean/adjust/replace :: : 3-22
Wiring and connectors Check/reconnect ::—
Bolts and nuts Tighten ::—
Lubrication points Grease : 3-25
To Next Page
Loading...
