Yamaha F40BWHD - Periodic Check and Adjustment

E
CHK
ADJ
CHAPTER 3
PERIODIC CHECK AND ADJUSTMENT
MAINTENANCE INTERVAL CHART
..............................................................3-1
TOP COWLING
...............................................................................................3-2
CHECKING THE TOP COWLING FIT .......................................................3-2
FUEL SYSTEM
................................................................................................3-2
CHECKING THE FUEL LINE ....................................................................3-2
CHECKING THE FUEL FILTER .................................................................3-3
CONTROL SYSTEM
.......................................................................................3-3
ADJUSTING THE SHIFT CABLE .............................................................3-3
ADJUSTING THE THROTTLE CABLE .....................................................3-4
ADJUSTING THE ENGINE IDLING SPEED ............................................3-5
ADJUSTING THE PILOT SCREW ............................................................3-6
EXHAUST GAS CONTROL PROCEDURES ............................................3-7
SYNCHRONIZING THE CARBURETOR ..................................................3-9
ADJUSTING THE DASH-POT ............................................................... 3-11
START-IN-GEAR PROTECTION DEVICE ADJUSTMENT
(MHD, WHD) .......................................................................................... 3-11
POWER UNIT
...............................................................................................3-12
CHECKING THE ENGINE OIL LEVEL ....................................................3-12
REPLACING THE ENGINE OIL AND OIL FILTER ..................................3-12
MEASURING THE OIL PRESSURE ....................................................... 3-13
ADJUSTING THE VALVE CLEARANCE ................................................3-14
MEASURING THE COMPRESSION PRESSURE .................................. 3-16
CHECKING THE TIMING BELT .............................................................3-17
COOLING SYSTEM
...................................................................................... 3-17
CHECKING THE COOLING WATER DISCHARGE ................................3-17