Buell 2002 S3T - Battery

2002 Buell S3T: Maintenance 1-11
HOME
BATTERY 1.3
GENERAL
Buell motorcycle batteries are permanently sealed, mainte-
nance-free, valve-regulated, lead/calcium and sulfuric acid
batteries. The batteries are shipped pre-charged and ready to
be put into service. Do not attempt to open these batteries for
any reason.
1WARNING1WARNING
All batteries contain electrolyte. Electrolyte is a sulfuric
acid solution that is highly corrosive and can cause
severe chemical burns. Avoid contact with skin, eyes,
and clothing. Avoid spillage. Always wear protective
face shield, rubberized gloves and protective clothing
when working with batteries. A warning label is attached
to the top of the battery. See Figures 1-1 and 1-2. Never
remove warning label from battery. Failure to read and
understand all precautions contained in warning label
before performing any service on batteries could result
in death or serious injury.
BATTERY TESTING
Voltmeter Test
See Table 1-5. The voltmeter test provides a general indicator
of battery condition. Check the voltage of the battery to verify
that it is in a 100% fully charged condition. If the open circuit
(disconnected) voltage reading is below 12.6V, charge the
battery and then recheck the voltage after the battery has set
for one to two hours. If the voltage reading is 12.8V or above,
perform the load test described in Section 7.
Table 1-4. Battery Electrolyte Antidotes
CONTACT SOLUTION
External Flush with water
Internal
Drink large quantities of milk or water, fol-
lowed by milk of magnesia, vegetable oil or
beaten eggs. Call doctor immediately.
Eyes
Flush with water, get immediate medical
attention.
Figure 1-1. Warning Label on Maintenance-Free Battery
MADE IN USA
H
A
R
L
E
Y
-D
A
V
ID
S
O
N
MILWAUKEE, WI 53201
M
A
D
E IN
U
.S.A
.
W
A
R
R
A
N
T
Y
A
N
D
A
D
J
U
S
T
M
E
N
T
P
O
L
IC
Y
This batte ry will be rep lace d witho ut cha rg
e
if found to be defective in materials or
workm
anship 12 months from
date of
vehicle purchase or 6 months from date
of over-the-counter purchase. After 6
m
onths, but within the 12 months of the
over-the-counte
r purch ase, the battery will
be replaced and the purchaser charged
only for the period of ownership based on
the regular price at the time of return
prorated ver the number of m
onths of
warran ty. This w arra nty is not transferable
and is voided by the use of rejuvenators,
improper electrolyte, neglect or abuse.
PART NO.
1234567890
JA FE MA AP MY JU JY AU SE OC NO DE
f1730x8x
Figure 1-2. Battery Warning Label
Contents
are Corrosive.
Wear
Safety Glasses.
Contents
are Explosive.
Keep
Flames Away.
Read
Instructions.
Keep Away
From Children.
f1733x8x