2
2.27
TRANSMISSION / GEARCASE
TRANSMISSION LUBRICATION
NOTE
It is important to follow the transmission maintenance
intervals described in the Periodic Maintenance Chart.
Regular lubricant level inspections should be performed
as well.
The transmission lubricant level should be checked and
changed in accordance with the maintenance schedule.
• Be sure vehicle is positioned on a level surface when
checking or changing the lubricant.
• Check vent hose to be sure it is routed properly and
unobstructed.
Transmission Lubricant Level Check
The fill plug is located on the right-hand side of the
transmission. Access the fill plug through the rear right-
hand wheel well. Maintain the lubricant level even with
the bottom threads of the fill plug hole.
1. Position vehicle on a level surface.
2. Remove the fill plug
q
and check the lubricant level.
NOTE
Wheel removed for clarity. Not required for transmission
oil check/change.
3. If lubricant level is not even with the bottom threads,
add the recommended lubricant as needed. Do not
overfill.
4. Reinstall the fill plug and torque to specification.
TORQUE
Drain/Fill Plug:
14 ft-lbs (19 Nm)
Transmission Lubricant Change
Access the drain plug through the rear right-hand
wheel well. The plastic skid plate can be removed for
better access to the drain plug.
5. Remove the fill plug (refer to “Transmission Lubricant
Level Check”).
6. Place a drain pan under the transmission drain plug.
7. Remove drain plug
w
and allow lubricant to drain
completely.
8. Clean the drain plug magnetic surface.
9. Reinstall drain plug with a new O-ring and torque to
specification.
10. Add the recommended amount of lubricant through
the fill plug hole. Maintain the lubricant level at the
bottom of the fill plug hole when filling the
transmission. Do not overfill.
FLUID CAPACITY
Recommended Transmission Lubricant:
Polaris AGL
Capacity:
37 oz (1100 mL)
11. Reinstall fill plug with a new O-ring and torque to
specification.
TORQUE
Drain/Fill Plug:
14 ft-lbs (19 Nm)
12. Check for leaks. Dispose of used lubricant properly.
MAINTENANCE
To Next Page
Loading...
