Amsco Evolution HC-600 - Page 10

viii
P129390-106 Operator Manual Table of Contents
Section
Number Description Page
9.4.2 Too Long In Jacket Charge........................................................................................................ 9-17
9.4.3 Too Long To Seal OE/NOE Door...............................................................................................9-17
9.4.4 Too Long To Unseal OE/NOE Door........................................................................................... 9-18
9.4.5 Chamber Pressure Transducer Failure...................................................................................... 9-18
9.4.6 Chamber Temperature Probe Failure ........................................................................................ 9-19
9.4.7 Jacket Temperature Probe Failure............................................................................................. 9-19
9.4.8 OE/NOE Door Switch Failure..................................................................................................... 9-20
9.4.9 Recorder Temperature Probe Failure ........................................................................................ 9-20
9.4.10 OE/NOE Door Switches Malfunction.........................................................................................9-21
9.4.11 Exhaust Rate Too Slow............................................................................................................. 9-21
9.4.12 Exhaust Rate Too Fast ............................................................................................................. 9-22
9.4.13 Generator Alarm........................................................................................................................ 9-22
10 Service Procedures.....................................................................................................................10-1
10.1 General ................................................................................................................................................ 10-1
10.2 Air Filter Replacement ......................................................................................................................... 10-1
10.3 Clean Jacket Steam Strainers ............................................................................................................. 10-2
10.4 Door Seal Replacement Procedure ..................................................................................................... 10-2
10.5 Steam Trap Replacement.................................................................................................................... 10-6
10.6 Clean or Replace Piping Check Valves ............................................................................................... 10-6
10.7 Safety Valve Test................................................................................................................................. 10-7
10.8 Recommended Spare Parts ................................................................................................................ 10-7
10.9 Waste Products Disposal................................................................................................................... 10-10