Amsco Evolution HC-600 - Page 9

vii
Table of Contents Operator Manual P129390-106
Section
Number Description Page
8 Routine Maintenance.....................................................................................................................8-1
8.1 Preventive Maintenance Schedule ........................................................................................................ 8-1
8.2 Daily Procedures ................................................................................................................................... 8-3
8.2.1 Clean Chamber Drain Strainer..................................................................................................... 8-3
8.2.2 Clean Chamber............................................................................................................................ 8-4
8.3 Weekly Maintenance: Flush Chamber Drain ......................................................................................... 8-5
8.4 Maintenance As Required ..................................................................................................................... 8-5
8.4.1 Change Printer Paper Roll ...........................................................................................................8-5
8.4.2 Change Printer Ink Cartridge ....................................................................................................... 8-9
9 Troubleshooting ............................................................................................................................9-1
9.1 General.................................................................................................................................................. 9-1
9.1.1 Typical Alarm Screen................................................................................................................... 9-2
9.1.2 Typical Alarm Printout.................................................................................................................. 9-3
9.2 In-Cycle Alarms ..................................................................................................................................... 9-3
9.2.1 Too Long In Charge ..................................................................................................................... 9-3
9.2.2 Too Long In Exhaust....................................................................................................................9-4
9.2.3 Too Long In Evacuation ............................................................................................................... 9-5
9.2.4 Too Long In Air Break .................................................................................................................. 9-6
9.2.5 Under Sterilize Temperature........................................................................................................ 9-6
9.2.6 Over Sterilize Temperature.......................................................................................................... 9-7
9.2.7 OE/NOE Door Unsealed .............................................................................................................. 9-7
9.2.8 Chamber Pressure/Temperature Failure ..................................................................................... 9-8
9.2.9 Recorder Deviation Alarm............................................................................................................ 9-8
9.2.10 Steam Utility Failure.................................................................................................................... 9-9
9.2.11 Water Utility Failure..................................................................................................................... 9-9
9.2.12 Air Utility Failure........................................................................................................................ 9-10
9.3 Out-of-cycle Alarms ............................................................................................................................. 9-11
9.3.1 Too Long To Close OE (or NOE) Door ...................................................................................... 9-11
9.3.2 Too Long To Open OE (or NOE) Door....................................................................................... 9-12
9.3.3 Pressure In Chamber................................................................................................................. 9-12
9.3.4 Waste Temperature Probe Failure............................................................................................. 9-13
9.3.5 RTC Failure................................................................................................................................ 9-13
9.3.6 Emergency Stop Button Pressed............................................................................................... 9-14
9.3.7 Input/Output Fault – Module #X ................................................................................................. 9-14
9.3.8 UPS Battery Low........................................................................................................................ 9-15
9.4 Sensor Alarms ..................................................................................................................................... 9-16
9.4.1 Water In Chamber...................................................................................................................... 9-16