Danfoss Turbocor TT Series User Manual

l
Section 5: Troubleshooting–thissectiondescribestroubleshootingusingsignalsfromthe
compressortodeterminethespecificsourceoffaultsatthesystemandcompressorlevel
l
Section 6: Maintenance–thissectioncontainsatablecontainingalistoftasksthatshouldbe
performedonaregularbasistomaintainoptimalperformanceofthesystem
l
Appendix A: Acronyms/Terms–thissectionprovidesdefinitionsoftermsandacronymsusedin
thismanual
l
Appendix B:Compressor Troubleshooting Flowcharts –thissectioncontainsflowchartstoassist
youwithcompressortroubleshooting
l
Appendix C: Compressor Test Sheet–thissectioncontainsasheetwithtestpoints,expected
values,andthesectioninthemanualassociatedwithaparticulartest
Thefollowingconventionsareusedinthismanual:
l
Procedures–alluserproceduresarelistedinnumericalsteps,unlessitisaone-stepprocedure.A
one-stepprocedureisshownasabullet.
l
UserActionRequired(software)–ifauserisrequiredtotakeactioninasoftwareprocedure,the
actionwillbeshowninbold.Example;WhentheLoginwindowopens,typeinyour name and
password.
l
MonitoringProgramWindowNames–allwindownameswillbeinitalic.ExampleCompressor
Controller window.
l
InternalReferences–referencestosectionswithinthismanualareencapsulatedinquotes.
Example,Isolatethecompressorpowerasdescribedinthe“ElectricalIsolationoftheCompressor"
sectionofthismanual.
l
ExternalReferences–referencestoitemsnotwithinthismanualareunderlined.Example;Referto
theTTS/TGS/TTH/TGHApplicationsManualforinstallationprocedures.

1.4 Commitment to Quality and the Environment
DanfossTurbocorCompressors(DTC)isdedicatedtoleadingthroughinnovationandtosatisfyingourcustomers
withthebestquality,value,andon-timedeliveryofhigh-efficiencyoil-freecentrifugalcompressors.
Wearecommittedtocontrollingourimpactontheenvironmentdemonstratedthroughsettinggoalsfocusedon
continualimprovementandcomplyingwithallrelevantlegislation,regulation,andotherrequirementstoprotect
theenvironment.
1.5 Safety Summary
Safetyprecautionsmustbeobservedduringinstallation,start-up,andserviceofthecompressorduetothe
presenceofpressureandvoltagehazards.Onlyqualifiedandtrainedpersonnelshouldinstall,startup,andservice
DanfossTurbocorcompressors.Safetyinformationislocatedthroughoutthemanualtoalertservicepersonnelof
potentialhazardsandisidentifiedbytheheadingsDANGER andCAUTION.
1.5.1 Danger Notification
ADANGER notificationsignifiesanessentialoperationormaintenanceprocedure,practice,orconditionwhich,if
notstrictlyobserved,couldresultininjurytoordeathofpersonnelorlong-termhealthhazards.ADanger
notificationisdisplayedintheformatshowninFigure1-3DangerNotificationExample.
Figure 1-3 Danger Notification Example
• • • DANGER! • • •

Page 20 of 294 - M-SV-001-EN Rev. H 1/23/2023

Danfoss Turbocor TT Series Specifications

General

Brand	Danfoss
Model	Turbocor TT Series
Category	Air Compressor
Language	English