Danfoss Turbocor TT Series User Manual

4.17.2.3SoftStartAC/DCHarnessInstallation-TTS300/TGS230 137
4.17.2.4SoftStartAC/DCHarnessInstallation-TTS/TGS/TTH/TGH(ExceptTTS300/TGS230) 138
4.17.2.5SoftStartAC/DCHarnessTorqueSpecifications 140
4.18Silicone-ControlledRectifier 141
4.18.1SCRConnections 141
4.18.2SCRVerification 142
4.18.2.1DiodesVerification-Two-HoleMount 142
4.18.2.2DiodesVerification-Four-HoleMount 143
4.18.2.3GatesVerification 144
4.18.2.4SCRTemperatureSensor 144
4.18.2.5SCRTemperatureSensorVerification 144
4.18.2.6SCRTemperatureSensorGeneralRemoval 145
4.18.2.7SCRTemperatureSensorRemoval-TTS300/TGS230 145
4.18.2.8SCRTemperatureSensorRemoval-TTS/TGS/TTH/TGHRev.FandEarlier(ExceptTTS300/TGS230) 146
4.18.2.9SCRTemperatureSensorInstallation-TTS300/TGS230 148
4.18.2.10SCRTemperatureSensorInstallation-TTS/TGS/TTH/TGHRev.FandEarlier(Except
TTS300/TGS230) 148
4.18.2.11SCRTemperatureSensorGeneralInstallation 148
4.18.2.12SCRTemperatureSensorTorqueSpecifications 148
4.18.3SCRRemovalandInstallation 149
4.18.3.1SCRGeneralRemoval 149
4.18.3.2SCRRemoval-TTS300/TGS230 149
4.18.3.3SCRRemoval-TTS/TGS/TTH/TGH(ExceptTTS300/TGS230) 150
4.18.3.4SCRInstallation-TTS300/TGS230 153
4.18.3.5SCRInstallation-TTS/TGS/TTH/TGH(ExceptTTS300/TGS230) 155
4.18.3.6SCRGeneralInstallation 156
4.18.3.7SCRTorqueSpecifications 156
4.19SCRCoolingManifold 157
4.19.1SCRCoolingManifoldGeneralRemovalSteps 157
4.19.2SCRCoolingManifoldSpecificRemovalSteps-TTS300/TGS230 157
4.19.3SCRCoolingManifoldSpecificRemovalSteps-TTS/TGS/TTH/TGH(ExceptTTS300/TGS230) 159
4.19.4SCRCoolingManifoldSpecificInstallationSteps-TTS300/TGS230 160
4.19.5SCRCoolingManifoldSpecificInstallationSteps-TTS/TGS/TTH/TGH(ExceptTTS300/TGS230) 160
4.19.6SCRCoolingManifoldGeneralInstallationSteps 162
4.19.7SCRCoolingManifoldTorqueSpecifications 162
4.20SnubberCapacitors 164
4.21DCCapacitorBusBarAssembly 165
4.21.1DCCapacitorDCBusBarConnections 166
4.21.2DCBusVoltageVerification 167
4.21.2.1BleedResistorVerification 167
4.21.2.2SnubberCapacitorVerification 167
4.21.3DCCapacitorBusBarAssemblyRemovalandInstallation 168
4.21.4DCCapacitorBusBarAssemblyGeneralRemoval 168
M-SV-001-EN Rev. H-1/23/2023 Page 7 of 294

Danfoss Turbocor TT Series Specifications

General

Brand	Danfoss
Model	Turbocor TT Series
Category	Air Compressor
Language	English