LM Trac 287 - Engine Air Filter Replacement (24); Replace (O)

LM 287 User Manual – 30.10.2023
81
6.12.4 Engine air filter replacement (24)
To ensure a long operating life for a modern, turbo‐charged engine, maintaining the good condition of the air filter is
essential.
NOTE
If the machine is operated in dusty or otherwise dirty conditions, the air
filter must be cleaned and replaced in shorter intervals.
WARNING
Never open the air filter while the engine is running!
Figure 98 Figure 99
1. Filter case
2. Safety element (605129022340)
3. Filter element (605129022350)
4. Filter case cover
5. Dust pocket
6. Cover fasteners
► Turn off the engine.
► Open two filter cover fasteners (6) and remove the cover (4).
► Remove the filter element (3) by rotating and pulling it out from the case.
NOTE
Do not remove the safety element (2) from its place unless it has to be
replaced.
► Clean the inside of the cover (4) and the filter element case (1) by wiping.
► Replace the filter element (3).
INFO
Do not use compressed air.
► Clean and check the dust pocket (5). If the dust pocket is damaged or does not close properly, replace it with a new
one.
INFO
If the filter element is damaged, the safety element must also be replaced.
► Otherwise, check the condition of the safety element, but do not remove it if it is in working order.
►If the safety element is dirty, do not clean it, but replace both elements.
INFO
The safety element must be replaced no later than when the main element
has been replaced five times.
► Inspect the condition of the filter element’s rubber seals.
► Install the filter element and protective cover in the reverse order.