Polaris RANGER EV 2015

2
9926595 R01 - 2015-2016 RANGER EV Service Manual
© Copyright Polaris Industries Inc.
2.3
ITEM
MAINTENANCE INTERVAL
(WHICHEVER COMES FIRST)
REMARKS
HOURS CALENDAR PAGE
Brake Systems -
Pre-Ride
-
Wheels / Fasteners
-
Pre-Ride
-
Frame Fasteners
-
Pre-Ride
-
Head Lamp / Tail Lamp -
Daily
-
Check operation; apply dielectric grease to
connector if replacing
▶
■
Brake Pad Wear 10 H
Monthly
-
Inspect periodically
▶
■
Parking Brake Cable
Adjustment
25 H
- - Inspect; adjust after first 25 hours
Battery Terminals (Clean)
25 H
Monthly -
Clean terminals and cable ends
Battery Terminals (Torque)
25 H
Monthly
- Re-torque terminal nuts
Battery Fluid Level
25 H
Monthly - Inspect and add distilled water as needed
▶
Front Gearcase Lubricant 25 H
Monthly - Inspect level; change yearly
▶
Transaxle (Rear Gearcase)
Lubricant
25 H
Monthly - Inspect level; change yearly
▶
General Lubrication 50 H 3 Months
- Lubricate fittings, pivots, cable ends
■ Steering
50 H 6 Months
- Inspect; Lubricate
▶
Front Suspension
50 H 6 Months
-
Check fastener torque; Check that cotter
pins are in place on castle nuts. Check
and lubricate tie rod ends.
▶
Rear Suspension
50 H 6 Months
-
Check fastener torque; Check that cotter
pins are in place on castle nuts. Lubricate
stabilizer bar pivots and A-arm joints.
▶
Wiring
100 H 12 Months
-
Inspect for wear, routing, security; apply
dielectric grease to non-sealed connectors
subjected to water, mud, etc.
■ Front Wheel Bearings
100 H 12 Months
- Inspect; replace as needed
■
Brake Fluid 200 H 24 Months
- Change every two years (DOT 4)
■ Toe Adjustment -
Inspect periodically; adjust when parts are
replaced
Headlight Aim - Adjust as needed
▶ Perform these procedures more often for vehicles subjected to severe use.
E Emission Control System Service (California)
■ Have an authorized Polaris dealer perform these services.
MAINTENANCE