Home
STEP
Controller
AS380 Series
STEP AS380 Series User Manual
4
of 1
of 1 rating
300 pages
Give review
Manual
Specs
To Next Page
To Next Page
To Previous Page
To Previous Page
Loading...
Shanghai S
TEP
Electri
c Corporatio
n
46
Chapter 4
The Wiring Of Elevator integrated Drive Controller
4.6.3 main extension board SM.09I0/C introduction
4.6.3.1
main extension
board
SM.09I0/C o
utside view
and
installation
dimension
Fig. 4.18
The outside view
of mai
n extension board SM.
09I
0/C
Fig. 4.19
The installation dim
ension of main extens
ion board SM.09I
0/C
55
57
Table of Contents
Forward
3
Table of Contents
6
Chapter 1 General Knowledge of the Integrated Drive Controller
11
Scope of Application
11
Items in the Cases
11
Model Description
11
Integrated Drive Controller Nameplate
12
Notice Items for Safety
12
Operation Notice
14
Brake Resistor Selection
14
Absorber at the Output Side Prohibited
15
The Application Voltage of Integrated Device
15
Two-Phase Input Not Allowed
15
Altitude and Derated Application
16
Synchronous Sealing Star Delay
16
Low Voltage Directive Complies
16
Waste Disposal
17
Disposal of Capacitors
17
Disposal of Plastic Components
17
Chapter 2 Model and Specification
19
Model of Integrated Drive Controller
19
The Technical Specification of Integrated Drive Controller
19
The Installation Dimensions and Mass of the Integrated Drive Controller
21
Installation Instructions
23
Product Installation Location
23
Product Installation Positioning and Clearance Requirements
24
Chapter 3 Product Function
25
Function List
25
Elevator Operation Function Description and Setting Method
27
Standard Function Description
27
Optional Function Description
32
Chapter 4 Wiring of Elevator Integrated Drive Controller
35
The Connection between Integrated Drive Controller and Peripheral Equipments
36
For Typical Terminal Wiring Diagram of Elevator Integrated Drive Controller
36
Notice Items for Peripheral Equipments Connection
37
Power Supply
37
Breaker
37
AC Reactor at the Input Side
37
Interference Filter at the Input Side
37
Main Circuit Output Contactor
37
Interference Filters at the Output Side
37
AC Reactor at Output Side
37
DC Reactor
38
Elevator Integrated Drive Controller
38
The Cable Requirement of Hoist Way and Accompanying Cable Arrangement
38
Method of Wiring between Call Board and TXV+、TXV-、TXA+、TXA
39
Hoist Way Switch Position
40
Upper and Lower Leveling Inductor
41
Main Circuit Terminal Wiring
43
The Arrangement of Main Circuit Terminal
43
The Main Circuit Terminal Labeling and Function Description
43
Main Circuit Wire Specification
43
The Main Circuit Composition
46
The Detailed Description of Main Circuit Terminal Wiring
46
Anti-Interference Measures
50
The Specialized Noise Filter Connected at the Output Side
50
Main Circuit Wiring Arrangement
50
The Better Anti-Interference Measure
51
Relation between Wiring Length and Carrier Frequency
51
Wiring of Control Circuit Terminals
52
Layout of Control Circuit Terminals
52
Functional Description of Control Circuit Terminals
52
Dip Switch Setting Method
55
Wire Specification of Control Circuit
55
Main Extension Board SM.09I0/C Introduction
56
Notice Items for Control Circuit Terminal Wiring
58
The Wiring of PG Card Terminals
58
PG Card - Incremental ABZ 12V
58
PG Card - SIN/COS
61
PG Card - Incremental ABZ 5V
64
PG Card - Endat with Absolute Value
66
Precaution for PG Card Terminal Wiring
68
Chapter 5 Operator
69
The 7-Segment Display Operator
69
LED Indicator Light
69
Function Key
70
Operator Handling
71
Graphic Symbol of Number and Letter on LED Screen
85
LCD Handheld Operator
85
LCD Handheld Operator Introduction
85
Handheld Operator Connection Method
87
Handheld Operator Function
88
Introduction to Display Interface of LCD Hand-Held Operator
89
Chapter 6 Introduction to the Supporting Products
115
Car Top Control Board SM.02/H Introduction
116
Car Top Control Panel SM.02/H Outside View and Installation Dimension
116
Car Top Control Panel SM 02/H
117
Car Top Extension Board SM09I0/B Introduction
120
Car Top Extension Board SM09IO/B Outside View and Installation Dimension
120
Car Top Extension Board SM09IO/B Plug-In and Port Definition Introduction
121
Car Controller Panel SM.02/G Introduction
122
Car Controller Panel SM02/G Outside View and Installation Dimension
122
Car Control Board SM.02/G Plug-In and Port Definition Introduction
123
Instruction Control Board SM-03
126
Instruction Control Board SM-03 Outside View and Installation Dimension
126
Instruction Controller Board SM-03 Plug-In and Port Definition Introduction
126
Call & Display Control Board
128
Call &Display Control Board SM.04VR/K
128
Call& Display Control Board SM-04-HSC
129
Call & Display Control Board SM-04-VHL
130
Call & LCD Control Board SM-04-UL
132
Car Call & LCD Control Board SM-04-VL
134
In-Car SM-04-VL/B3 Outside View and Installation Dimension
136
Call& LED Display Control Panel SM-04-VSD
138
Call & LED Display SM-04-VRJ
140
Miscellaneous (a List of Display Codes)
141
SM.GC/C Board Introduction
143
System Structure
143
Basic Feature
144
Main Functions
145
Input of Call Button Signal and Control of Call Button Light
148
General Principle of Overall Deploy
148
Treatment in Special Situation
149
Instruction of Group Control Board (SM.GC/C)
150
Connection Method of Group Control System
157
Setting of Group Control Operation
157
Instruction of Group Control Program to Setup Parameters
158
Chapter 7 Parameter Table of Integrated Drive Controller
173
F Parameter List
173
Definition of Function Parameter
182
Chapter 8 Elevator Elevator Commissioning Guide
205
Check before Power on
208
Power on and Check
208
Confirmation before Power on
208
Checks after Power on
209
Configuration of System Basic Parameters and Self Study of Motor Parameters
209
Configuration of System Basic Parameters
209
Motor Parameter Self Study
211
Test Run of Slow Car
212
Inspection Operation of Engine Room and Preparations for Express Car
212
Car Top Inspection Operation
213
Check of CAN Communication Lines and Setting of 04 Board Address
214
Door Opening/Closing Adjustment
215
Hoist Way Self Study
215
Hoistway Self Study Method
215
Express Car Operation
216
Adjust Elevator Comfort
220
Factors Relating to Elevator Comfort in Operation
220
Leveling Adjustment
228
Method for Adjusting Pre-Load Weighing Compensation at Elevator Start
234
Use of DTZZ-III-DC-SC
236
Use of Non-DTZZ-III-DC-SC Weighing Device (F164 Set to 1, 2, 5 or 6) to Compensate or Adjust the Start
237
Simple Compensation by Using Light-Load and Heavy-Load Switch (F164 Set to 4)
238
The Adjustment of Other Function
239
Chapter 9 Faults and Solutions
241
The Fault Analysis of the Integrated Device Control System
241
Fault Analysis of Integrated Drive System
247
Chapter 10 Maintenance
253
Warranty
253
Product Checkup
254
Routine Inspection
254
Periodic Inspection
254
Appendix A EMC Installation Guide
257
A1 Noise Control
257
A1.1 Noise Type
257
A1.2 Transmission Path
257
A1.3 Basic Measures for Noise Suppression
258
A2 Requirements on Cable Laying
259
A2.1 Requirement on Cable Laying
259
A2.2 Requirements on Cable Size
260
A2.3 Requirements on Shielded Cable
260
A2.4 Requirements on Installation of Shielded Cable
260
A3 Grounding Requirements
260
A3.1 Grounding Method
260
A3.2 Precautions for Grounding Connection
261
A4 Install Surge Absorption Device
261
A5 Leakage Current and Countermeasures
262
A5.1 Ground Leakage Current
262
A5.2 Line-To-Line Leakage Current
262
A6 Suppression of Radiated Emission
263
A7 Guide for Use of Power Line Filter
264
A7.1 Functions of Power Line Filter
264
A7.2 Precautions for Installation of Power Line Filter
264
A8 EMC Installation Zoning
264
A9 Precautions for Electric Installation
265
A10 EMC Conformity
267
Appendix B Function Parameter, Fault List Summary
269
Function Parameter List
269
Fault Code and Analysis
283
Appendix C Inverter Complies with the Standards
297
Notice to Customers
299
4
Based on 1 rating
Ask a question
Give review
Questions and Answers:
Need help?
Do you have a question about the STEP AS380 Series and is the answer not in the manual?
Ask a question
STEP AS380 Series Specifications
General
Brand
STEP
Model
AS380 Series
Category
Controller
Language
English
Related product manuals
STEP AS380-4T05P5
271 pages
STEP AS380-4T07P5
271 pages
To Next PageTo Next PageTo Previous PageTo Previous Page
Loading...
Need help?
General
