Case 570NXT - Page 110

To Next Page

To Previous Page

6-WORKINGOPERATIONS

8.PressEscape(1)toreturntotheInstrumentCluster

Dimmerscreen.

9.Usethearrowstonavigatetoadifferentmenuscreen

orpressEscapeuntilyoureturnthemainscreen(en-

ginehourmeter).

RAPH12UTL0172AA4

6-2

Main Page

Table of Contents2
General Information9
Intended Use9
CNH America LLC Technical Manuals10
Electro-Magnetic Compatibility (EMC)11
Note to the Owner11
Read the Operator's Manual12
Manual Storage12
Right, Left, Front and Rear of the Machine13
Component Identification14
Product Identification Number (PIN)17
Safety Information25
Safety Rules25
Safety Rules - California Proposition 65 Warning26
Safety Rules - General27
Safety Rules - Air Conditioning System27
Safety Rules - Basic Operating28
Safety Rules - Battery29
Safety Rules - Electrical Storm Safety30
Safety Rules - Fire or Explosion Prevention30
Safety Rules - Fuel Handling Precautions31
Safety Rules - Hazardous Chemicals31
Safety Rules - Lifting and Overhead Loads31
Safety Rules - General Maintenance Precautions32
Safety Rules - Mounting and Dismounting33
Safety Rules - Operator Precautions33
Safety Rules - Specific Precautions to this Machine34
Safety Rules - Transporting Precautions34
Safety Rules - Utility Precautions35
Safety Rules - Wheels and Tires36
Safety Rules - Ductile Iron36
Safety Rules - Roll over Protective Structure (ROPS)37
Safety Rules - Seat Belt38
Safety Signs39
Hand Signals58
Do Not Operate Hang Tag60
Controls/Instruments61
Access to Operator's Platform61
Machine Access61
Operator's Seat62
Operator Seat62
Forward Controls65
Front Controls65
Pedal Controls67
Right-Hand Side Controls68
Loader Functions68
Console Controls71
Rear Hitch Controls76
Cab Controls and Adjustments78
Advanced Instrument Cluster (AIC)79
Menu Screen Display84
Operating Instructions89
Commissioning the Unit89
Run in Period of a New Machine89
Engine Speed89
Starting the Unit90
Before Starting the Engine90
Normal Engine Starting91
Cold Temperature Operation92
Hot Temperature Operation94
Booster Battery Procedure95
Stopping the Unit97
Shutting down the Engine97
Moving the Unit98
Uniform Braking98
Traveling on a Hill99
Machine Direction99
Transmission Gears100
Before Operating the Machine101
Differential Lock System102
Four Wheel Drive (4WD) Control103
Ride Control (if Equipped)104
Transport Operations105
Road Transport105
Transporting on a Trailer105
Recovery Transport107
Towing the Machine107
Working Operations109
General Information109
Display Brightness109
Maximum Throttle/Cold Start Idle111
Brake Enabled Idle113
Throttle Sensitivity115
Regeneration Inhibit116
Oil Life Reset118
Loader Operations120
Personal Safety120
Job Layout121
Comfort Steer (if Equipped)122
Detent Position for 4 in 1 Bucket Control Switch123
Loader Digging Force126
Bucket Level, Position and Depth Indicators127
Return to Dig129
Lifting with the Loader131
Changing Loader Attachments131
Three Point Hitch134
General Safety and Precautions134
Machine and Attachments135
Working Operations136
Maintenance143
General Information143
Safety Rules143
General Safety before You Service144
Hour Meter144
Support Strut for Loader Lift Arm145
Hood Latch147
Fire Extinguisher148
Battery Access and Care149
Welding on the Machine151
Fuses and Relays153
Definition of Fuse, Relay and Diode Icons157
Diagnostic/Service Tool Port - Diagnostic Service Tool Port161
Heater Coolant Shutoff Valve161
Fluid Capacities and Lubricant Specifications162
Consumables163
Maintenance Chart165
At Warning Message Display168
Engine Air Filters168
Hydraulic Filter(S)170
Fuel System Water Separator171
Diesel Particulate Filter (DPF) Regeneration - Automatic173
Diesel Particulate Filter (DPF) Regeneration - Forced174
Initial 10 Hours177
Air Conditioning Belt177
Wheel Nut and Bolt Torque178
Every 10 Hours or Daily179
Engine Oil Level179
Grease Fittings180
Initial 20 Hours183
Transmission Oil Level183
Front Axle Fluid Level - Four Wheel Drive185
Rear Axle Fluid Level186
Every 50 Hours187
Fuel System Water Separator187
Coolant Reservoir (Deaeration Reservoir) Fluid Level189
Hydraulic Reservoir Fluid Level190
Front Axle Grease Fittings191
Loader Hydraulic Coupler Lock Pins192
In 1 Bucket Pivots and Grease Fittings192
Initial 100 Hours194
Hydraulic Filter194
Transmission Filter196
Fuel Filters198
Service Brakes200
Parking Brake201
Every 250 Hours202
Battery202
Air Conditioning Belt203
Front Axle Fluid Level - Four Wheel Drive204
Front Axle Breather205
Front Axle Drive Shaft205
Rear Axle Fluid Level206
Rear Axle Breather206
Rear Axle Drive Shaft206
Fuel Tank207
Transmission Fluid Level208
Air Conditioning Compressor Seals209
Every 500 Hours210
ROPS Cab and Seat Mount210
Operator's Seat211
Fuel Filters212
Engine Oil and Filter214
Battery Fluid Level216
Every 1000 Hours217
Hydraulic Fluid and Filter(S)217
Hydraulic Reservoir Breather219
Cab Intake Filter220
Front Axle Fluid221
Rear Axle Fluid223
Transmission Fluid and Filter224
Engine Air Filters226
Parking Brake228
Every 2000 Hours229
Cooling System229
Every 3000 Hours232
Diesel Particulate Filter (DPF)232
Every 4000 Hours232
Engine Crankcase Ventilation (CCV) Filter232
As Required233
Windshield Washer Fluid Level233
Bleed Air from the Fuel System234
Hydraulic Pump236
Tire Pressure237
Operator's Seat238
Grille Screen and Radiator Area240
Fan Belt241
Accumulator243
Disable Parking Brake244
Electrical System246
Stop, Tail, Flasher and Turn Signal Lamps - Cab246
Stop, Tail, Flasher and Turn Signal Lamps - Canopy - ROPS Canopy248
Driving and Flood Lamps250
Specifications253
Engine253
Powertrain254
Hydraulics255
Electrical Specifications256
Machine Overall Dimensions257
Loader Lift Capacities263
Three Point Linkage General Specifications264
Torque265
General Specification - Biodiesel Fuels - Biodiesel Fuels267
Accessories269
General Accessories269
Telematics - Overview with Case Sitewatch271

Case 570NXT - Page 110

Table of Contents

Other manuals for Case 570NXT

Related product manuals