Merits Pilot - Table of Contents

i
Table of Contents
1.Introduction 1-1
1.1. Intended Use ................................................................................................... 1-1
1.2. How to Use Installation and Service Manual ................................................. 1-1
1.3. Safety Rules .................................................................................................... 1-1
1.4. Warranty .......................................................................................................... 1-2
2.Installation 2-1
2.1. Unpack and verify the shipment ..................................................................... 2-1
2.2. Determine handing .......................................................................................... 2-3
2.3. Cut the rail to length as required ..................................................................... 2-3
2.3.1. Stairs Measurement ................................................................................ 2-4
2.3.2. Determine the Rail Length ..................................................................... 2-4
2.4. Connect rail sections together (if required) .................................................... 2-5
2.5. Install Bottom Rail Accessories ...................................................................... 2-6
2.6. Install Rail Assembly on Stairs ....................................................................... 2-6
2.7. Install Racks on Rail Assembly ...................................................................... 2-7
2.8. Install Carriage on Rail ................................................................................... 2-8
2.8.1. Slide Carriage onto Rail ......................................................................... 2-8
2.8.2. Engage Carriage Gear with Rack on Rail ............................................ 2-10
2.8.3. Move Carriage Down by Remote Controller ....................................... 2-10
2.8.4. Install Accessories on Top Rail Section ................................................ 2-11
2.8.5. Adjust Location of Top and Bottom Limit Switch Cams ..................... 2-11
2.9. Install Footrest Assembly ............................................................................. 2-12
2.9.1. Check Handing of Footrest .................................................................. 2-12
2.9.2. Switch Handing of Footrest (if required) ............................................. 2-12
2.9.3. Assemble Footrest ................................................................................ 2-13
2.9.4. Plug in Connector to Carriage Footrest Cable ..................................... 2-14
2.10.Install Seat Assembly .................................................................................... 2-14
2.10.1. Check Handing of Seat ........................................................................ 2-14
2.10.2. Change Handing of Armrest (if required) ............................................ 2-15
2.10.3. Adjust Armrest Width (if required) ...................................................... 2-16
2.10.4. Adjust Seat Height (if required) ........................................................... 2-17
2.10.5. Plug in Seat Control Cable ................................................................... 2-17
2.10.6. Secure Seat on Seat Post ...................................................................... 2-18
2.11. Install Covers ................................................................................................ 2-18
2.11.1. Install Seat Post Cover ......................................................................... 2-18
2.11.2. Install Carriage Side Covers ................................................................ 2-19
2.11.3. Install Carriage Rubber Plugs .............................................................. 2-19
2.12.Install Charger ............................................................................................... 2-20
2.13.Install Mechanical Stop ................................................................................ 2-20