2-2
Periodic Maintenance
Chart
A = Adjust I = Inspect
C = Clean L = Lubricate
D = Drain R = Replace
T = Tighten
* Service/Inspect more frequently when operating in adverse conditions.
Item
Initial
Service After
Break-In
(First Mo or
100 Mi)
Every
Day
Every Month
or
Every 100
Miles
Every 3
Months or
Every 300
Miles
Every 6
Months or
Every 500
Miles
Every Year
or Every
1500 Miles
As
Needed
Battery I I C
Fuses IR
Air Filter/Drain Tube I I C* R
Valve/Tappet Clearance I I A
Engine Compression I
Spark Plug I I I R (4000 Mi
or 18 Mo)
Muffler/Spark Arrester CR
Gas/Vent Hoses I I R (2 Yrs)
Throttle Cable Ends/Accelerator Pedal
Pivot
II C-L A-R
Carb Float Chamber D*
Engine RPM (Idle) I I A
Engine-Transmission Oil Level I A
Engine-Transmission Oil/Filter R R* R
Oil Strainer I I C
Front Differential/Rear Drive Lubricant I I R (4 Yrs)
Tires/Air Pressure I I R
Steering Components I I I R
V-Belt I l R
Suspension (Ball joint boots, drive
axle boots front and rear, tie rods, dif-
ferential and rear drive bellows)
II R
Nuts/Bolts/Cap Screws T T A
Ignition Timing I
Headlight/Taillight-Brakelight I I R
Switches I I R
Shift Lever IA-L
Gauges/Indicators I I R
Frame/Welds I I l
Electrical Connections lC
Complete Brake System
(Hydraulic & Parking)
II
Brake Pads I I* R
Brake Fluid I I R (2 Yrs)
Brake Hoses I I R (4 Yrs)
Coolant/Cooling System I I R (2 Yrs)
Wheel Lug Nuts T T
Back to TOC
Back to Section TOC
Next
FOR ARCTIC CAT ATV DISCOUNT PARTS CALL 606-678-9623 OR 606-561-4983
www.mymowerparts.com
To Next Page
Loading...
