ATV 200 - Chapter II MAINTENANCE AND ADJUSTMENT OF VEHICLE; Section 1 Periodic Maintenance;Lubrication

Chapter II MAINTENANCE AND
ADJUSTMENT OF VEHICLE
Note:
The correct maintenance and adjustment are necessary to ensure vehicles,
normal driving.The repair personnel should be familiar with the contents of this article.
Section 1 Periodic Maintenance/Lubrication
Item
Valve
Spark plug
Air filter
Carburetor
Cylinder head
Exhaust system
Spark surpressor
Oil circuit
Engine oil
Oil filter
Oil filter screen
Gear case oil
Brake
Clutch
Wheel
Wheel bearing
Front&Rear suspension system
Steering system
Connecting piece and fastener
Bearing of steering
verticle column
Requirement
Check the valve clearance.Adjust it if necessary.
Check the clearance and clean the plug. Replace it if necessary.
Clean it. Replace it if necessary.
Check the idle or starting state.Adjust it if necessary.
Check it there is crack or damage in gas tube.Replace it if necessary.
Check the leakage.Tighten it again if necessary.Replace the gasket if necessary.
Clean
Check the cracks or damage of oil tube.Replace it if necessary.
Replace.(Preheat the engine before draining the oil)
Clean
Clean
Check the oil level and leakage.Replace.
Check the operation.Adjust it if necessary.
Check the operation.Adjust it if necessary.
Check the balance,damage,run-out etc.Replace it if necessary.
Check the looseness and damage.Replace it if necessary.
Check the operation and correct it if necessary.
Check the operation and corrcet it if necessary.Check the toe-in and adjust it if necessary.
Lubricate every 6 months (lithium soap grease)
Check all the connecting piece and fasteners of chassis correct them if necessary.
Every time
Every
1
month
3
month
6
month
6
month
1
year
¡ð
¡ð
¡ð
¡ð
¡ð
¡ð
¡ð
¡ð
¡ð
¡ð
¡ð
¡ð
¡ð
¡ð
¡ð
a¡ð
¡ð
¡ð
¡ð
¡ð
¡ð
¡ð
¡ð
¡ð
¡ð
¡ð
¡ð
¡ð
¡ð
¡ð
¡ð
¡ð
¡ð
¡ð
¡ð
¡ð
¡ð
¡ð
¡ð
¡ð
¡ð
¡ð
¡ð
¡ð
¡ð
¡ð
¡ð
¡ð
¡ð
¡ð
¡ð
¡ð
¡ð
¡ð
.We advise that the maintenance of these items should be conducted by our saler.
- 31 -