1-14 - GENERAL INFORMATION and SPECIFICATIONS 90-817643R1 DECEMBER 1996
Lubrication Points
Engine
Crankshaft
Splines to
Drive Shaft
Splines
Throttle/Shift
Linkage
Pivot Points
Item
No.
Description
Type of
Lubricant
Fresh Water
Frequency
Salt Water
Frequency
Upper
Shift
Shaft
Swivel Pin
Ride Guide
Steering
Cable
Tilt Tube
Steering
Link Rod
Pivot Points
Propeller
Shaft
Starter Motor
Pinion Gear
Gear
Housing
Bearing
Carrier
Gear
Housing
Quicksilver
2-4-C w/Te-
flon
Marine
Lubricant
Every
60 Days
Every
30 Days
SAE 30W
Motor Oil
Once in
Season
After first 20
Hours, then
once in
season
Check and fill
after first 10
days, then
every 30 days
Drain and re-
fill after 1st 25
hours, then
after every
100 hours, or
once a year
before storing
Every
60 Days
Every
30 Days
Quicksilver
-Anti-Corro-
sion Grease
Every
60 Days
SAE 30W
Motor Oil
Once in
Season
Every
60 Days
Check and fill
after first 10
days, then
every 30 days
Drain and re-
fill after 1st 25
hours, then
after every
100 hours, or
once a year
before storing
Once in
Season
Once in
Season
Quicksilver
Gear Lube
∆
◊
1
2
3
4
5
6
7
8
9
*
10
Quicksilver
2-4-C w/Te-
flon
Marine
Lubricant
Quicksilver
2-4-C w/Te-
flon
Marine
Lubricant
* Refer to lubrication instructions outlined in “Salt Water Corrosion -
Gear Housing Bearing Carrier and Cover Nut” of this section (see
“Table of Contents”).
◊ Refer to “Gear Housing Lubrication” of this section (see “Table of
Contents”).
∆ Refer to “Gear Housing Removal and Installation” (Section 5).
50554
1
1
1
1
1
1
1
1
1 - Throttle/Shift Linkage Pivot Point Lubrication
51122
2
2
2 - Upper Shift Shaft Lubrication
To Next Page
Loading...
