Polaris 2008 sportsman 800efi - Page 24

2.6
MAINTENANCE
Hours Calendar Miles (KM)
, E Fuel system 100 H 12 M 620 (1000)
Check for leaks at tank cap, lines, fuel pump, filter,
pump, injectors; replace lines every two years
, E
Fuel filter
(if equipped)
100 H 12 M 620 (1000) Replace yearly (if equipped)

Radiator
(if applicable)
100 H 12 M 620 (1000) Inspect; clean external surfaces

Cooling hoses
(if applicable)
100 H 12 M 620 (1000) Inspect for leaks
 Engine mounts 100 H 12 M 620 (1000) Inspect
Exhaust
muffler/pipe
100 H 12 M 620 (1000) Inspect
, E Spark Plug 100 H 12 M 620 (1000) Inspect; replace as needed
, E Ignition Timing 100 H 12 M 620 (1000) Inspect
 Wiring 100 H 12 M 620 (1000)
Inspect for wear, routing, security; apply dielectric
grease to connectors subjected to water, mud, etc.

Clutches
(drive & driven)
100 H 12 M 620 (1000) Inspect; clean; replace worn parts

Front wheel
bearings
100 H 12 M
1000
(1600)
Inspect; replace as needed
 Brake fluid 200 H 24 M
1240
(1000)
Change every two years
 ADC fluid 200 H 24 M
1240
(1000)
Change every two years
Spark arrestor 300 H 36 M
1860
(3000)
Clean out
E Idle Speed ---- Adjust as needed
 Toe Adjustment ---- Inspect periodically; adjust when parts are replaced
, 
Auxiliary brake ---- Inspect daily, adjust as needed
Headlight aim ---- Adjust as needed
 = Perform these procedures more often for vehicles subjected to severe use.
E = Emission Control System Service (California)
 = Have an authorized Polaris Dealer perform these services.
Table 2-1: REQUIRED MAINTENANCE INTERVALS
ITEM MAINTENANCE INTERVAL REMARKS