0C-4 Service Data:
Throttle Body
Thermostat + Radiator + Fan + Coolant
Electrical
Unit: mm (in)
Item
Specification
E-02, 03, 19, 24, 28, 54 E-33
ID No. 05H0 05H1
Bore size 38 mm (1.5 in) ←
Fast idle r/min 1 500 – 2 000 r/min ←
Idle r/min 1 450 ± 100 r/min ←
Throttle cable play 2.0 – 4.0 mm (0.08 – 0.16 in) ←
Item Standard / Specification Limit
Thermostat valve opening
temperature
Approx. 82 °C (180 °F) —
Thermostat valve lift Over 3 mm (0.12 in) at 95 °C (203 °F) —
Engine coolant temperature sensor
resistance
20 °C (68 °F) Approx. 2.58 kΩ —
50 °C (122 °F) Approx. 0.77 kΩ —
80 °C (176 °F) Approx. 0.28 kΩ —
110 °C (230 °F) Approx. 0.12 kΩ —
Radiator cap valve opening
pressure
93.3 – 122.7 kPa (0.93 – 1.23 kgf/cm
2
, 13.3 – 17.4 psi) —
Cooling fan thermo-switch operating
temperature
OFF → ON Approx. 98 °C (208 °F) —
ON → OFF Approx. 92 °C (198 °F) —
Engine coolant type
Use an anti-freeze/coolant compatible with aluminum
radiator, mixed with distilled water only, at the ratio of 50 : 50.
—
Engine coolant including reserve
Reserve tank side Approx. 250 ml (0.3/0.2 US/Imp oz) —
Engine side Approx. 1 700 ml (1.8/1.5 US/Imp oz) —
Item Standard / Specification Note
Spark plug
Type NGK: CR7E DENSO: U22ESR-N
Gap 0.7 – 0.8 (0.28 – 0.03)
Spark performance Over 8.0 (0.3) at 1 atm.
CKP sensor resistance 190 – 290 Ω G – Bl
CKP sensor peak voltage 4.5 V and more
(+) probe: G/W,
(–) probe: Bl
Ignition coil resistance
Primary 1.2 – 3.5 Ω
Secondary 15 – 30 kΩ
Ignition coil primary peak voltage 150 V and more (When cranking)
(+) probe: W,
(–) probe: Ground
Generator coil resistance Charging 0.1 – 1.0 Ω Y – Y
Generator no-load voltage
(When engine is cold)
55 V and more at 5 000 r/min
Generator Max. output Approx. 400 W at 5 000 r/min
Starter motor brush length
Standard 7 (0.28)
Limit 3.5 (0.14)
Regulated voltage 14.0 – 15.5 V at 5 000 r/min
Starter relay resistance 3 – 6 Ω
Battery
Type designation FTZ9-BS
Capacity 12 V 32.4 kC (9 Ah)/10 HR
Fuse size
Headlight
HI 10 A
LO 10 A
Meter 15 A
Ignition 10 A
Signal 15 A
Fan motor 10 A
Main 30 A
To Next Page
Loading...
