2007 Buell P3: Maintenance 1-13
HOME
BRAKE SYSTEM MAINTENANCE 1.6
GENERAL
Check the master cylinder reservoirs for proper fluid levels
after the first 1000 miles (1600 km) and every 5000 miles
(8000 km) thereafter. Also inspect fluid levels at the end of
every riding season.
Check brake pads and rotors for wear at every service inter-
val. See 1.7 BRAKE PADS AND ROTORS.
Replace
D.O.T. 4 BRAKE FLUID
:
●
Every 2 years.
It is recommended to inspect both front and rear brake lines
and replace as required:
●
Every 4 years.
It is recommended to inspect both front and rear caliper and
master cylinder seals and replace as required:
●
Every 2 years.
Check rear brake pedal operation:
●
Before every ride.
Lubricate the front brake hand lever:
FLUID LEVEL
See Figure 1-5. With motorcycle in a level position, check that
brake fluid is between the upper and lower marks on front and
rear reservoirs. Add
D.O.T. 4 BRAKE FLUID
if necessary. Be
sure gasket and cap on reservoir fit securely.
BLEEDING BRAKES
11WARNING1WARNING
Direct contact of D.O.T. 4 brake fluid with eyes can cause
irritation. Avoid eye contact. In case of eye contact flush
with large amounts of water and get medical attention.
Swallowing large amounts of D.O.T. 4 brake fluid can
cause digestive discomfort. If swallowed, obtain medical
attention. Use in well ventilated area. KEEP OUT OF
REACH OF CHILDREN. (00240a)
.
Figure 1-5. Rear Brake Fluid Reservoir
Figure 1-6. Front Brake Caliper Bleeder Valve
Figure 1-7. Rear Brake Caliper Bleeder Valve (Metric)
To Next Page
Loading...
