DAELIM DAYSTAR - Page 129

13-2
Front Wheel/Front Fork/Steering
Tools
Special
Ball Race Driver
Steering Stem Driver
Fork Seal Driver
Steering Stem Socket
Common
Extension Bar
Driver
Fork Seal Driver Body
Lock Nut Wrench 30×32mm
Bearing Remover shaft
Remover Head
Attachment 42×47mm
Attachment 37×40mm
Pilot 12mm
Troubleshooting
Hard steering
● Steering bearing adjusting nut too tight.
● Steering head, bearing worn, damage
● Inner, outer race worn, damage
● Insufficient tire pressure
● Worn Tire
Steers to one side
● Steering head bearing damage, loose
● Unevenly adjusted right and left cushions
● Bent front fork
● Bent front axle shaft, wheel installed incorrectly
● Worn tire
● Worn wheel bearings
● Worn swing arm pivot
Front wheel wobbling
● Bent rim
● Worn wheel bearings
● Spoke bent, loose
Soft suspension
● Weak fork springs
● Insufficient fluid
● Contaminated oil
● Low fluid weight in fork
Hard suspension
● Bent fork tubes
● Too much oil
● High fluid weight in fork
● High tire pressure
Front fork noise
● Faulty bottom case
● Fork assembling part loose
● Insufficient fluid in fork