DAELIM DAYSTAR Service Manual

15-9
Hydraulic Brake
Installation
Connect the brake hose to the caliper, and
install the 2 sheets of sealing washer and brake
hose bolt.
Torque: 3.4kgf-m
Install the slide pin cap.
Fill the brake fluid and bleed the mixed air.
( 15-3)
Master Cylinder
Removal
Disconnect the brake light switch wires from
the switch. Drain the brake fluid from the
hydraulic system. ( 15-3)
Remove the brake hose from the master
cylinder.
• Brake fluid can cause damage to painted,
plastic, and rubber surfaces.
If attached, place a rag over the these parts or
clean them with brake fluid or water. Cover the
hose joint part to prevent break fluid leakage.
• Clean the removed parts with brake fluid, check
for the clogged passage with compressed air.
• Do not allow dust and dirt to stick to the
removed parts.
Remove the master cylinder holder, and take
off the master cylinder.
Disassembly
Remove the rear mirror, brake lever, and stop
switch.
Remove the piston boot and snap ring form
master cylinder.
Tool: Snap ring plier
!
CAUTION
△
Brake Hose
Brake Hose
Brake Hose
Brake Hose
Brake Hose
Brake HoseBrake Hose
Brake Hose
Brake Hose
Brake Hose
Brake Hose
Brake Hose
Brake Hose
Brake Hose Bolt
Brake Hose Bolt
Brake Hose Bolt
Brake Hose Bolt
Brake Hose Bolt
Brake Hose BoltBrake Hose Bolt
Brake Hose Bolt
Brake Hose Bolt
Brake Hose Bolt
Brake Hose Bolt
Brake Hose Bolt
Brake Hose Bolt
Master Cylinder
Master Cylinder
Master Cylinder
Master Cylinder
Master Cylinder
Master CylinderMaster Cylinder
Master Cylinder
Master Cylinder
Master Cylinder
Master Cylinder
Master Cylinder
Master Cylinder
Brake Hose Bolt
Brake Hose Bolt
Brake Hose Bolt
Brake Hose Bolt
Brake Hose Bolt
Brake Hose BoltBrake Hose Bolt
Brake Hose Bolt
Brake Hose Bolt
Brake Hose Bolt
Brake Hose Bolt
Brake Hose Bolt
Brake Hose Bolt
“UP” Mark
“UP” Mark
“UP” Mark
“UP” Mark
“UP” Mark
“UP” Mark“UP” Mark
“UP” Mark
“UP” Mark
“UP” Mark
“UP” Mark
“UP” Mark
“UP” Mark
Brake Lever
Brake Lever
Brake Lever
Brake Lever
Brake Lever
Brake LeverBrake Lever
Brake Lever
Brake Lever
Brake Lever
Brake Lever
Brake Lever
Brake Lever
Brake Right Switch
Brake Right Switch
Brake Right Switch
Brake Right Switch
Brake Right Switch
Brake Right SwitchBrake Right Switch
Brake Right Switch
Brake Right Switch
Brake Right Switch
Brake Right Switch
Brake Right Switch
Brake Right Switch
Brake Hose Bolt
Brake Hose Bolt
Brake Hose Bolt
Brake Hose Bolt
Brake Hose Bolt
Brake Hose BoltBrake Hose Bolt
Brake Hose Bolt
Brake Hose Bolt
Brake Hose Bolt
Brake Hose Bolt
Brake Hose Bolt
Brake Hose Bolt

DAELIM DAYSTAR Specifications

General

Fuel System	Carburetor
Front Suspension	Telescopic Fork
Front Brake	Disc
Rear Brake	Drum
Engine Type	4-Stroke, Air-cooled
Displacement	124 cc
Transmission	5-speed
Fuel Capacity	12.5 liters
Weight	125 kg
Rear Suspension	Dual shock absorbers