2007 Buell Lightning: Maintenance 1-9
HOME
BATTERY MAINTENANCE 1.4
GENERAL
Buell motorcycle batteries are permanently sealed, mainte-
nance-free, valve-regulated, lead/calcium and sulfuric acid
batteries. The batteries are shipped pre-charged and ready to
be put into service. Do not attempt to open these batteries for
any reason.
Inspect the battery for damage or leaks and for clean, non-
corroded connections:
● At the 1000 mile (1600 km) service interval.
● At every scheduled service interval thereafter.
1WARNING1WARNING
Batteries contain sulfuric acid, which could cause severe
burns to eyes and skin. Wear a protective face shield,
rubberized gloves and protective clothing when working
with batteries. KEEP BATTERIES AWAY FROM CHIL-
DREN. (00063a)
1WARNING1WARNING
A warning label is attached to the top of the battery. See
Figure 1-1. Never remove warning label attached to top of
battery. Failure to read and understand all precautions
contained in warning, could result in death or serious
injury. (00064a)
1WARNING1WARNING
Battery posts, terminals and related accessories contain
lead and lead components, chemicals known to the State
of California to cause cancer and birth defects or other
reproductive harm. Wash hands after handling. (00019a)
BATTERY TESTING
Voltmeter Test
See Table 1-4. The voltmeter test provides a general indicator
of battery condition. Check the voltage of the battery to verify
that it is in a 100% fully charged condition. If the open circuit
(disconnected) voltage reading is below 12.6V, charge the
battery and then recheck the voltage after the battery has set
for one to two hours. If the voltage reading is 12.8V or above,
perform the load test described under 7.11 BATTERY.
Table 1-3. Battery Electrolyte Antidotes
CONTACT SOLUTION
External Flush with water.
Internal
Drink large quantities of milk or water,
followed by milk of magnesia, vegeta-
ble oil or beaten eggs. Call doctor
immediately.
Eyes
Flush with water, get immediate med-
ical attention.
Figure 1-1. Battery Warning Label
Table 1-4. Voltmeter Test For Battery Charge
VOLTAGE (OCV) STATE OF CHARGE
12.7 100%
12.6 75%
12.3 50%
12.0 25%
11.8 0%
To Next Page
Loading...
Need help?
General
