2007 Buell Lightning: Maintenance 1-41
HOME
AIR CLEANER FILTER 1.14
REMOVAL
CAUTION
Install air filter before running engine. Failure to do so
can draw debris into the engine and could result in
engine damage. (00207a)
Check air cleaner filter element:
● Inspect at the 1000 mile (1600 km) service interval and
at every 5000 mile (8000 km) service interval thereafter.
● Replace at every 20,000 mile (32,000 km) service interval.
NOTES
● Inspect and replace air cleaner filter element more often
if the motorcycle is run in a dusty environment.
● See Figure 1-39. Do not cover or restrict the air intake
screen. Certain tank bags or accessories may cover or
restrict the air intake screen. This may reduce power and
performance.
1. Remove seat. See 2.44 SEAT.
2. Remove intake cover assembly. See 2.38 INTAKE
COVER ASSEMBLY.
3. See Figure 1-40. or Figure 1-42. Remove fuel vent tube
(4) from vapor valve (6) at front of air cleaner cover and
groove on top of air cleaner cover (1).
4. See Figure 1-43. Unlatch six latching tabs and remove
air cleaner cover from baseplate.
5. See Figure 1-44. Remove the filter element (1) from
baseplate (2). Inspect and replace if necessary.
CAUTION
See Figure 1-44. Cover the velocity stack so nothing can
drop into the motor.
CLEANING AND INSPECTION
1WARNING1WARNING
Do not use gasoline or solvents to clean filter element.
Flammable cleaning agents can cause an intake system
fire, which could result in death or serious injury.
(00101a)
1. Check filter element. Hold filter element up to strong light
source. The element can be considered sufficiently clean
if light is uniformly visible through the element.
2. Thoroughly clean baseplate and inside of air cleaner
cover.
3. See Figure 1-45. Make sure two crankcase breather
hoses (1) and intake air sensor (2) are captured in base-
plate behind velocity stack (3).
Figure 1-39. Air Intake Screen
Figure 1-40. Air cleaner cover, Fuel Vent Tube and Fuel
Vapor Valve (XB12 solid color models)
Figure 1-41. Actuator Cover for XB12 Models with
translucent body panel.
12049
2
3
1
4
5
1. Air cleaner cover
2. Actuator (interactive exhaust)
3. Fuel vent tube
4. Cable (interactive exhaust)
5. Harness (interactive exhaust)
6. Vapor valve
6
To Next Page
Loading...
Need help?
General
