MAINTENANCE
2-4
PRE-RIDE - 25 HOURS MAINTENANCE INTERVAL
Periodic Maintenance Chart
Item
Maintenance Interval
(Whichever comes first)
Remarks
Hours Calendar Km
â—†
Front- Suspension - Pre-Ride - Make adjustments as needed.
â—†
Rear- Suspension - Pre-Ride -
Make adjustments as needed.
Tire - Pre-Ride -
Make adjustments as needed.
Brake fluid lever Pre-Ride
Make adjustments as needed.
â–
Brake Pedal Travel Pre-Ride
Make adjustments as needed.
Brake system - Pre-Ride -
Check Operation
Wheels/ Fasteners - Pre-Ride -
Make adjustments as needed.
Frame fasteners - Pre-Ride -
Make adjustments as needed.
â—†
Engine oil lever - Pre-Ride -
Make adjustments as needed.
Air filter - Pre-Ride -
Inspect; clean often, replace as
needed.
â–
Coolant lever - Pre-Ride -
Inspect coolant lever.
â—†
Air filter Daily
Drain deposits when visible.
Head lamp/ tail lamp Daily
Check operation; apply dielectric
grease if replacing.
CVT housing Weekly
Drain water as needed, check
often if operating in wet
conditions.
Battery 25H Monthly 500
Check terminals; clean; test.
â—†
Transmission oil change 25H
40H
Monthly
12M
500
1000
Inspect level; change yearly;
perform break-in oil change after
the first 25 hours of operation.
â–
â—†
Engine oil change * Severe duty
**Normal Duty
25H
50H
Monthly
12M
500
1000
Inspect level; change yearly;
Perform a break-in oil change at
during cold weather
â–
Radiator 25H
50H
Monthly
12M
500
1000
Inspect external surface; change
coolant
Perform a break-in oil change at
25 hours,
â—†
Oil pre-filter screen 50H 12M 1000
Clean filter at every oil change;
â–
Perform these procedures more often for vehicles subjected to severe use.
â—†
Have an authorized AEON dealer perform these services.
To Next Page
Loading...
Need help?
General
