Philips BiPAP AVAPS - Humidification

1118824, VER. 00
CHAPTER 5: TROUBLESHOOTING AND ERROR CODES
5.0 INTRODUCTION................................................................................................................5-1
5.1 READING THE DEVICE’S ERROR LOG...............................................................................5-1
5.2 CLEARING THE DEVICE’S ERROR LOG .............................................................................5-2
5.3 ERROR CODES ...............................................................................................................5-3
5.4 BENCH CHECKOUT .......................................................................................................5-11
CHAPTER 6: NIV DEVICE REPAIR & REPLACE
6.0 REPLACEMENT PART (RP) KITS FOR PR SYSTEM ONE NIV DEVICES ..............................6-3
6.1 REPLACEMENT INSTRUCTIONS.........................................................................................6-5
6.1.1 Replacing the SD Card Slot Cover ...................................................................................... 6-5
6.1.2 Replacing the User Interface (UI) Knob .............................................................................. 6-6
6.1.3 Replacing the Right Side Cover .......................................................................................... 6-7
6.1.4 Replacing the Top Cover ..................................................................................................... 6-8
6.1.5 Replacing the UI Panel ......................................................................................................... 6-9
6.1.6 Replacing the Keypad ........................................................................................................ 6-10
6.1.7 Replacing the End Panel.................................................................................................... 6-11
6.1.8 Replacing the Main PCA ....................................................................................................6-12
6.1.9 Replacing the Blower Cap ................................................................................................. 6-14
6.1.10 Replacing the Blower Assembly and/or the Blower Outlet Bellows............................ 6-16
6.1.11 Replacing the Flow Manifold ........................................................................................... 6-18
6.1.12 Replacing the Right Panel Assembly ............................................................................. 6-19
6.1.13 Replacing the Humidifier Cable....................................................................................... 6-20
6.1.14 Replacing the Blower Housing........................................................................................ 6-21
6.1.15 Replacing the Alarm Assembly and/or Alarm Holder ................................................... 6-22
6.1.16 Replacing the Sound Abatement Foam.......................................................................... 6-24
6.1.17 Replacing the Air Inlet Seal .............................................................................................6-25
6.1.18 Replacing the Bottom Enclosure .................................................................................... 6-26
6.2 CLEANING THE DEVICE .................................................................................................6-27
6.3 CLEANING AND REPLACING THE FILTERS.......................................................................6-27
6.4 CLEANING THE PATIENT TUBING ...................................................................................6-28
6.5 CLEANING THE HUMIDIFIER TANK ..................................................................................6-28
6.6 SYSTEM RUN-IN ............................................................................................................6-29
CHAPTER 7: HUMIDIFIER REPAIR AND REPLACEMENT
7.0 HUMIDIFIER REPLACEMENT PART (RP) KITS ...................................................................7-1