Daewoo NUBIRA - Scheduled Maintenance Chart - Chassis and Body

GENERAL INFORMATION 0B – 11
DAEWOO V–121 BL4
Chassis and Body
Maintenance Item Maintenance Interval
Miles (Kilometers) or time inmonths, whichever comes first
x 1,000 miles
6 12 18 24 30 36 42 48 54 60 66 72 78 84 90 96 102
x 1,000 km
9.6 19.2 28.8 38.4 48 57.6 67.2 76.8 86.46 96 105.6 115.2 124.8 134.4 144 153.6 163.2
# Months
6 12 18 24 30 36 42 48 54 60 66 72 78 84 90 96 102
Air Filter (A/C) (2)
R R R R R R R R R R R R R R R R R
Exhaust pipes & mountings
I* I* I* I* I* I* I* I*
Brake/Clutch fluid (3)(5)
I I R I I R I I R I I R I I R I
Brake pads & discs(6)
I I I I I I I I I I I I I I I I
Parking brake
I I I I I I I
Brake line & connections (In-
cluding booster)
I I I I I I I I I I I I I I I I
Rear hub bearing & clearance
I I I I I I I I
Manual Transaxle Oil (3)
I I I I I I I I
Clutch & brake pedal free play
I I I I I I I I I I I I I I I I I
Automatic transaxle fluid* (3) (7)
I I I I R I I I
Chassis & underbody bolts &
nuts, tighten/secure
I I I I I I I I I I I I I I I I I
Tire condition & inflation pres-
sure
I I I I I I I I I I I I I I I I I
Wheel alignment (8)
Inspect when abnormal condition is noted.
Tire rotation
Rotate tires every 6,000 miles
Steering wheel & linkage
I I I I I I I I I I I I I I I I I
Power steering fluid & lines*
I I I I I I I I
Drive shaft boots
I I I I I I I I I I I I I I I I I
Seat belts, buckles & anchors
I I I I I I I I I I I I I I I I I
Lubricate locks, hinges & hood
latch
I I I I I I I I
Chart Symbols:
I – Inspect these items and their related parts. If necessary, correct, clean, replenish, adjust or replace.
R – Replace or change.
(2) More frequent maintenance is required if driving under dusty conditions.
(3) Refer to”Recommended Fluids And Lubricants.”
(5) Change the brake/clutch fluid every 9,000 miles (14,400 kilometers) or 9months, whichever comes first, if the vehicle
is operated under any of the following conditions :
– Driving in hilly or mountainous terrain.
(6) More frequent maintenance is required if the vehicle is operated under any of the following conditions:
– Short–distance driving.
– Extensive idling or slow–speed driving in stop–and–go traffic.
– Driving on dusty roads.
(7) Change the automatic transaxle fluid every 50,000miles (80,000 kilometers) if the vehicle is operated under any of the
following conditions :
– Driving in hilly or mountainous terrain.
– Driving in heavy city traffic where the outside temperatures regularly reach 32³C (90³F) or higher.
– Driving a taxi, or police or delivery vehicles.
(8) If necessary, rotate and balance the wheels
Note : Check the engine oil and radiator coolant levels ev-
ery week.