SECTION 3 - INDUSTRIAL APPLICATION
53
F32 SERIES
Pri nt P2D32F005 E Base - April 2009
FAILURE POSSIBLE ROOT CAUSE
RECOMMENDED TESTS
OR REMEDY
NOTES
Theenginedoesnotstart Discharged of damaged battery Check the battery and recharge it.
Replace the battery if necessary
Battery terminal conn ections corroded
or loose
Clean, check and tighten the battery ter-
minal screw nuts. Replace the terminals
and the screw nuts if excessively cor-
roded.
Incorrect timing of the ignition pump Check the ignition pump timing. Apply to FPT Technical Ser-
vice.
Deposits or water presence in the fuel
tank
Disconnect the pipes and c lean them
with co mpressed air jet. Disassemble the
ignition pump and clean it. E liminate any
presence of water in the fuel tank and
refuel.
Always bleed the supply sys-
tem.
Insufficient fuel reserve Refuel
No supply Overhaul or replace the supply or
transfer pumps
Air bubbles in the fuel pumps or in the
ignition pump
Check the pipes to ascertain the cause of
air presence and the supply pump. Elimin-
ate any air from the ignition pump interior
loosing the specially provided cap and
manually operating the supply pump.
Defective starter Repair or replace the starter
DIAGNOSIS BY FAILURE
In case of external EGR system failure, its operation is disabled and the related E GR failure indicator lamp
flashes (if applicable).
NOTE
To Next Page
Loading...
