Maeda LC1385M-8BF - Other Trouble; Electrical System

3-190
8.5 OTHER TROUBLE
8.5.1 ELECTRICAL SYSTEM
• : Always contact us or our sales service agency when dealing with these items.
• In causes of problems or causes which are not listed blow, contact us or our sales service agency for
repairs.
Problem
Main causes
Remedy
Lamp does not glow brightly
even when the engine runs at
high speed
• Defective wiring, deterioration
of battery
• Loose fan belt
• Defective alternator
Check, repair, loose terminals,
disconnections, replace battery
Replace fan belt, Check tension
Replace
Lamp flickers while engine is
running
Charge level monitor does not
go out even when engine is
running
• Defective alternator
• Defective wiring
• Loose fan belt
Replace
Check, repair
Replace fan belt, Check tension
Abnormal noise is generated
from alternator
• Defective alternator
Replace
Starter motor does not turn
when starter switch is turned to
START
• Defective wiring
• Defective starter motor
• Insufficient battery charge
Check, repair
Replace
• Charge
Pinion of starter motor keeps
going and out
• Insufficient battery charge
• Defective safety relay
• Charge
Replace
Starter motor turns engine
sluggishly
• Insufficient battery charge
• Defective starter motor
• Charge
Replace
Starter motor disengages before
engine starts
• Defective wiring, defective ring
gear and pinion
• Insufficient battery charge
Check, repair
• Charge
Starter motor turns but engine
does not start
• Defective engine controller
power supply circuit
• Defective relay
• Defective connector at engine
end
Replace
Replace
Check, repair for loose, missing
connector or disconnection
Engine pre-heating monitor
does not light up
• Defective wiring
• Defective heater relay
• Defective monitor
Check, repair
Replace
Replace
Engine oil pressure monitor
does not light up when engine is
stopped
(Starter switch at ON position)
• Defective monitor
• Defective caution lamp switch
• Defective oil pressure switch
Replace
Replace
Replace
Outside electrical heater is not
warm when touched by hand
• Defective wiring
• Disconnection in electric
heater
• Defective operation of heater
relay
Check, repair
Replace
Replace
Travel alarm does not sound
when travel lever is operated
• Defective wiring
• Defective alarm
• Defective travel PPC pressure
sensor
Check, repair for loose terminals
or disconnection
Replace
Replace
Rear-view monitor does not
show image
• Defective wiring
• Defective camera
• Defective monitor
Check, repair for loose, missing
connector or disconnection
Replace
Replace