Rapid 2005 - SECTION 12: INLET HOOD; 12.3 Inlet Hood Assembly (2020 and 2030)

B-SERIES INSTALLATION, OPERATION AND SERVICE MANUAL
54 of 147
12.3 Inlet Hood Assembly (2020 and 2030)
*For use on model 2030 Inlet Hoods only.
**For model 2020 P/N=13205095; for model 2030 P/N=13305100
Note: In the above chart, an "X" in a part number indicates a digit that changes based on model. Replace the
"X" with a "2" for model 2020; replace the "X" with a "3" for model 2030. For further clarification, reference
individual chart of components in each step.
Description
Model
Inlet Hood with Permanent
Aluminum Mesh Filters
Inlet Hood without filters,
with Birdscreen
Inlet Hood with
Moisture Limiter
2020
13205060 (Galvanized)
13205061 (Painted)
13205058 (Galvanized)
13205059 (Painted)
13205062 (Galvanized)
13205063 (Painted)
2030
13305060 (Galvanized)
13305061 (Painted)
13305058 (Galvanized)
13305059 (Painted)
13305062 (Galvanized)
13305063 (Painted)
Part
Number
Quantity Quantity Quantity
Double Sided Filter Rails 13X05066 4 4 N/A
Top Inner Filter Rail 13X05068 1 1 1
Bottom Rail 13X05072 1 1 N/A
Top Back Panel #1 13X05075 1 1 1
Top Middle Panel #2 13X05076 1 1 1
Top Front Panel #3 13X05077 1 1 N/A
Left Side Panel #1 13X05080 1 1 1
Right Side Panel #1 13X05081 1 1 1
Left Side Panel #2 13X05082 1 1 1
Right Side Panel #2 13X05083 1 1 1
Left Side Panel #3 13X05084 1 1 1
Right Side Panel #3 13X05085 1 1 1
Upright Mount 13X05090 2 2 2
Horizontal Mount 13X05091 2 2020=6 / 2030=2 2
Drip Rail Upper Right 13305092 1 1 1
Drip Rail Upper Left 13305093 1 1 1
Drip Rail Lower Right 13305094 1 1 1
Drip Rail Lower Left 13305095 1 1 1
TEK Screw 13404 150 2020=165 / 2030=175 2020=152 / 2030=162
5/16"-18 x 1 Bolt HHCS Grade 5 20507 26 26 26
3/8" Flatwasher 20515 14 14 14
3/8"-16 x 1 Bolt Hex Grade 5 20517 14 14 14
5/16" Flat Washer 95211600 26 26 26
5/16" Nut Flange 20509 26 26 26
Permanent Aluminum Mesh Filter
20" x 25" x 1"
20629 2020=10 / 2030=5 N/A N/A
Permanent Aluminum Mesh Filter
20" x 20" x 1"
20628 2020=0 / 2030=10 N/A N/A
10-24 KEPS Nut 20698 16 16 16
A1 Snap Fastener 20900 10 N/A N/A
10-24 x 1/2" HMS Bolt 27000 16 16 16
Fastener Rivnut 3/8"-16 91120106 14 14 14
Foam Tape 92700017 20' (6 m) 20' (6 m) 20' (6 m)
Birdscreen 9074005X N/A 1 N/A
Birdscreen Mount* 13305087* N/A 4* N/A
Fender Washer 1/4" x 1" 95211550 N/A 16 N/A
Bottom Rail - ML** ######** N/A N/A 1
Left Side Cover - ML 13X05078 N/A N/A 2
Right Side Cover - ML 13X05079 N/A N/A 2
Top Front Panel #3 - ML 13X05096 N/A N/A 1
Inner Rail - ML 13X05097 N/A N/A 1
Outer Rail - ML 13X05098 N/A N/A 1
Moisture Limiter 12" x 96" x 5.5" 90740002 N/A N/A 2020=4 / 2030=5