wsm M8540NARROW - Page 39

GENERAL
M8540Narrow, M9540Narrow, WSM
NG-17
IMPORTANT
• The jobs indicated by + must be done after the first 50 hours of operation.
• *1: Air cleaner should be cleaned more often in dusty conditions than in normal conditions.
• *2: Every year or every 6 times of cleaning.
• *3: Replace only if necessary.
• *4: When the battery is used for less than 100 hours per year, check the battery condition by reading the indicator annually.
9Y1210236GEG0007US0
23 Front axle case oil Change
every
1000 Hr
NG-33
24 Engine valve clearance Adjust
every
1000 Hr
NG-33
25
Fuel injection nozzle injection
pressure
Check
every
1500 Hr
NG-33
26 Turbocharger Check
every
3000 Hr
NG-33
27 Injection pump Check
every
3000 Hr
NG-33
28 Intake air heater Check
every
3000 Hr
NG-33
29 Cooling system Flush
every
2 years
NG-35
30 Coolant Change
every
2 years
NG-35
31 Master cylinder filter Clean
every
2 years
–
32 Master cylinder kit Replace
every
2 years
–
33 Equalizer kit Replace
every
2 years
–
34 Brake seal 1 and 2 Replace
every
2 years
–
35 Lift cylinder hose Replace
every
2 years
NG-37
36 Fuel system Bleed
Service
as re-
quired
NG-38
37 Brake system Bleed NG-38
38 Clutch housing water Drain NG-39
39 Fuse Replace NG-41
40 Light bulb Replace NG-41
41 Inner air filter Clean ,,,
every
200 Hr
NG-28
42 Fresh air filter Clean ,,,
every
200 Hr
NG-29
43 Air conditioner condenser Check ,,,
every
200 Hr
NG-29
44 Air conditioner drive belt Adjust ,,,
every
200 Hr
NG-29
45 Air conditioner pipes and hoses
Check
every
1 year
NG-34
Replace
every
2 years
NG-37
46 Cabin isolation cushion C
heck
every
1 year
NG-34
47 Washer liquid Add Service
as re-
quired
NG-40
48 Refrigerant (gas) Check NG-39
No. Item
Service Interval
After
since
Refer-
ence
page
50 100 150 200 250 300 350 400 450 500 550 600 650 700
KiSC issued 07, 2013 A