Amsco C Series - Page 9

viii
P129394-176 Operator Manual Table of Contents
Section
Number Description Page
9.3.1 Too Long To Close Door ....................................................................................................... 9-11
9.3.2 Too Long To Open Door ....................................................................................................... 9-12
9.3.3 Pressure In Chamber ............................................................................................................ 9-13
9.3.4 Waste Temperature Probe Failure ........................................................................................ 9-13
9.3.5 Atmospheric Pressure Alarm.................................................................................................9-14
9.3.6 Input/Output Board #1 Communication Failure ..................................................................... 9-15
9.3.7 ROM Failure .......................................................................................................................... 9-16
9.3.8 RAM Failure .......................................................................................................................... 9-16
9.3.9 ADC Failure ........................................................................................................................... 9-16
9.3.10 Emergency Stop Switch Pressed .......................................................................................... 9-17
9.4 Sensor Alarms ................................................................................................................................... 9-18
9.4.1 Water In Chamber ................................................................................................................. 9-18
9.4.2 Too Long In Jacket Charge ................................................................................................... 9-19
9.4.3 Too Long To Seal Door ......................................................................................................... 9-19
9.4.4 Too Long To Unseal Door ..................................................................................................... 9-20
9.4.5 Chamber Pressure Transducer Failure ................................................................................. 9-21
9.4.6 Chamber Temperature Probe Failure.................................................................................... 9-21
9.4.7 Jacket Temperature Probe Failure ........................................................................................ 9-22
9.4.8 Door Switch Failure ............................................................................................................... 9-23
9.4.9 Door Seal A Switch Malfunction ............................................................................................ 9-24
9.4.10 Board Overtemp Failure ........................................................................................................ 9-24
10 Service Procedures ..................................................................................................................... 10-1
10.1 General .............................................................................................................................................. 10-1
10.2 Air Filter Replacement ....................................................................................................................... 10-1
10.3 Clean Strainers .................................................................................................................................. 10-3
10.4 Door Seal Replacement Procedure ................................................................................................... 10-4
10.5 Steam Trap Replacement .................................................................................................................. 10-5
10.6 Clean or Replace Piping Check Valves ............................................................................................. 10-5
10.7 Rebuild Solenoid Valves .................................................................................................................... 10-6
10.8 Safety Valve Test............................................................................................................................... 10-6
10.9 Recommended Spare Parts............................................................................................................... 10-7
10.10 Waste Products Disposal................................................................................................................. 10-10
TABLE OF CONTENTS