CONTENTS
5
8024638/AE00/V1-0/2019-09 | SICK S E R V I C E M A N U A L | MCS200HW
Subject to change without notice
5.3.9 Replacing the chopper motor.................................................... 105
5.3.10 Replacing the filter wheel motor ............................................... 107
5.3.10.1 Filter wheel motor 1 ............................................... 108
5.3.10.2 Filter wheel motor 2 ............................................... 111
5.3.10.3 Filter wheel motor 3 ............................................... 113
5.3.11 Replacing the lens on filter wheel housing 1 ........................... 116
5.3.12 Replacing the LPMS03 detector cable ..................................... 117
5.3.13 Replacing the LPMS03 detector circuit board ......................... 118
5.3.14 Replacing the cable and light barrier on the filter wheel
motor .......................................................................................... 120
5.3.15 Replacing the LPMS04 circuit board ........................................ 121
5.3.16 Replacing the heating cartridges .............................................. 122
5.3.17 Replacing the PT100 temperature sensor ............................... 125
5.3.18 Replacing the sender/receiver windows .................................. 127
5.3.19 Adjusting the zero point............................................................. 128
5.4 Working on the electronics unit................................................................. 129
5.4.1 Removing and fitting the electronics unit................................. 129
5.4.2 Replacing the LPMS01 circuit board ........................................ 132
5.4.3 Replacing the LINUX CPU .......................................................... 135
5.4.3.1 Performing a firmware update............................... 137
5.4.3.2 Swapping the SD card............................................ 138
5.4.4 Replacing the LPMS02 circuit board ........................................ 139
5.4.5 Replacing the LPMS02 fan........................................................ 142
5.4.6 Replacing the LPMS01 to LPMS04 connection cable ............. 145
To Next Page
Loading...
Need help?
General
