tO
I
.....
0
Engine does not start.
Does engine turn over
with continued
cranking?
Yes
NO
NO
Does the flywheel
rotate?
:or turns slowly)
Yes
Check fuel syatem.
Starter does not stop
if
key start switch is
turned
of1.
Does starter rotate ?
NO
Check battery for charging condition
1---------
and
battery terminals for connections
_____
..,...
_______
.,
and
corrosion.
Yes
Is
there anything unusual about
the meshing
of
the pinion and
ring gear's teeth.
Check
the
pinion's overruning clutch
for damage.
Replace if necessary.
• Adjust
the
dimension
"e
".
(P.13)
• Check the shift lever for deforma-
tion. the torsion spring for exces-
sive wear and the pinion for its
sliding condition.
Yes
• Correct meshing condition of the /
pinion and the ring gear.
Replace
if
necessary.
._____
Check the battery's charge. the
ba11ery
terminals connections and
tor any corrosion.
NO
Check the consistency of the oil
in
the
engine.
Is
it
thick?
NO
Does engine turn over
if
the starter
is
replaced
?
Yes
---~
·1
Yes
Yes
NO
(or rotation is slow)
Inspect the inside of the engine.
OK
Can
you
bear
the
starter's magnetic
switch operating ?
Yes
Remove starter from engine.
Does starter turn under
no
load conditi-
ons
by connecting battery
EB·
terminal
lo
M terminal of starter and battery 8
terminal to the starter ground terminal?
Yes
• The magnetic switch connection
is
1au!ty
Replace
It.
Change
the
engine oil.
Repair or replace old starter.
Repair or replace key start switch.
starter relay or magnetic switch.
NO
NO
• Charge or replace battery.
• Repair connections and clean
corrosion ol battery terminals.
Check and repair wiring system and
connections between magnetic
---..i
switch and key start switch.
NO
Check and replace if necessary:
• Key atart switch.
• Magnetic switch. (P.10)
• Check the brush. If there is.fric-
tion, replace
it.
• If there
is
no wear and tear
on
the brush, replace the motor
( including
the
field coil and
armature.)
. -
..........
+.
,.
..
-
.....
+-o
..................................
•~
.............
-
••
' '
.
~-~
~---~
.
j{
}
----
i
: Check item Problem or :
: corrective action :
' .
..............
...........................................
-
................
.
CAUTION
If
any abnormality is found.
immediately disconnect battery
negative terminal.
To Next Page
