5 June 2020 CasTemp Wireless including CasTemp Superheat Page 5
Technical Data.
An entire overview of the QUBE CTW module safety statement can be found in Appendix 2: Safety
statement.
1.9.2 Wireless transmitter / receiver module
The Heraeus Electro-Nite CasTemp wireless instruments and QUBE CTW modules work with the
industrial transmitter / receiver module RM024 from Laird Technologies, which is approved worldwide.
There is a 10mW transmitter in both CTW and instrument. The device is transmitting intermittently for
~100mS, so the energy transmitted is small.
1.9.2.1 RM024 transmitter / receiver module
The RM024 Frequency Hopping Spread Spectrum Transceiver Module from Laird Technologies is a
robust and easy to use wireless module. It supports both high data rates and long distances and is
used in many machine-machine applications.
• Frequency range: 2400 - 2483.5 MHz
• Transmission distance: 100m (in-door), 1km (free-field)
• Transmission power: +10 dBs
1.9.3 Safety
• Frequency Hopping Radio Interface (Frequency Hopping Spread Spectrum = FHSS)
• System IDs
• Unique IEEE MAC addresses
• Protected Hardware
• Proof, autonomous transmission / reception protocol
• No conflicts with WLAN or WIFI
1.10 RoHS Regulations
All electrical devices sold in the European market from the 1 July 2006 must fulfil the EU Directive
2002/95/EC Restriction of the use of certain Hazardous Substances in Electrical and Electronic
Equipment (RoHS) as well as the national laws derived from it. According to the definition in Annex IB
of the EU Directive 2002/96/EC WEEE, Heraeus Electro-Nite measuring instruments and analysis
devices belong to category 9 - monitoring and control instruments.
All Heraeus Electro-Nite instruments placed on the market after 1 July 2006 do not contain materials
prohibited according to the RoHS directive.
Affected parts and components are identified and adapted to the statutory requirements and other
substances in those parts and components are utilised where necessary. The quality and usability of
our devices are not affected.
The adaptations are usually not visible, although adapted primary housing parts can show different
surface colour.
1.11 WEEE Regulations
Heraeus Electro-Nite devices are exclusively for commercial use and may not be transferred to
private use. Devices must be disposed of according to the national, statutory regulations for
According to the EU Directive 2002/96/EC Waste Electrical and Electronic Equipment (WEEE),
all electrical devices sold in the European market from the 13 August 2005 must be marked with
a special symbol. This symbol (crossed out waste disposal receptacle with thick black bar
underneath) indicates to the customer that the device must not be placed in household waste,
but must be either deposited at a collection place for commercial scrap or returned to the
manufacturer.
To Next Page
Loading...
