contact breaker points settings and odjust
if
necessary. Check ignition timing and
adjust
if
necessary.
Clean ond reset spark plug points. Check alternator mounting
bolts for tightness.
check all
'V'
belt condition and tension, adjust if necessary.
Check
arid adjust air conditioning compressor belt tension and check mounting bolts
for ti
g
htness (when fitted). Check security of all fixings especially engine mouritirig
bolts, exhaust manifold and carburetter mountings. Ctieck and adjust slow running
mixture and idle speed. Check security and cleanliness of ignition harness joints
including alternator and starter motor connections. Top up cooling system arid check
security and
conditiorl of all water hoses.
Fuel System
Check fuel system for leaks, fuel pipe corinections on carburetters, fuel pump fuel
tank and fuel filter. for. tightness.
Check entire system for
leaks and operation (includin
g
handbrake), and adjust if
necessary.
Check security of
all broke pipes arid vacuum pipe connections. Top up
brake fluid reservoir,
if
low check for cause. Check operation of brake fail/hand-
brake warning lamp. Check front and rear brake pads for material remaining,
if
down
:G
?-G
(LE3
I")
??'.!I\'.!MQbA,
:.P;!CCP
the
yds.
Check
~n!i:~r
mn~ntlna
ho!tc
nw
to
their specified torque loading.
Clutch
Ctieck and
if
necessary top up clutch1 fluid reservoir. Check operation of clutch
and adjust
if
necessary.
Steering and
Suspensiori
Check security of all steering connections, includin
g
columri clamps and mountings.
Check steering unit and anti
-
roll bar mountings for tightness. Ctieck condition of
anit
-
roll bar mounting rubbers. Check steering unit for oil leaks, and condition of
rubber bellows. Check front damper, wishbone and ball joint mounting bolts to
specified torque loadings. Check front and
rear wheels alignment.
Check rear radius
arm,
damper and lower link mounting bolts to specified torque loadings. Check all
steering and front and rear suspension moving parts for wear. Check and adjust front
ESPRIT
Issue
04/78
To Next Page
Loading...
