Lotus Esprit Series - Rear Quarter Light

BODY
Page B53
KEY TO FIG.22
TO REPLACE
Exterior Door Handle
Door Lock
Locking Rod to Exterior Hondle
Releose Rod to Exterior Handle
Locking Rod to lnterior Handle
Release Rod to lnterior Handle
Adjustable Cocking Rod to Exterior Handle
Clip Adjustable Release Rod to Exterior Handle
Clip Adjustable Locking Rod to lnterior Handle
Clip Adjustable Release Rod to lnterior Handle
1.
Reverse the removal procedure, but before replacin
g
the PVC sheeting
and the door trim panel, with the car on its wheels on level ground,
ensure that the door lock and the door handler are functioning
correctly. If not, adjust the control rods as necessary.
2.
To adjust the locking rod (C) from the exterior door handle to the lock
assembly, disconnect the rod from the exterior door handle and screw
it in OF out as required (G).
3.
All the other rods can be adjusted on their connecting clips (H, J
a K).
REAR QUARTER LIGHT
TO REMOVE
1.
From inside the engine compartment, remove the two fixing screws
securing the two tobs attached to the inside top of the quarter light.
Carefully
ease the two tobs through the quarter light opening while
pulling the top of the quarter light out. When the tabs are free of
the opening, lift the quarter
light assembly off the sill finisher ledge.
ESPRIT
Issue 04/78