Home
HP
Server
Integrity rx4640
HP Integrity rx4640 User Manual
5
of 1
of 1 rating
232 pages
Give review
Manual
Specs
To Next Page
To Next Page
To Previous Page
To Previous Page
Loading...
Chapter 7
Removing and Replacing Compone
nts
I/O Baseboard Assembly
173
Figure
7-19
I/O Baseboard
Replacing the I/O baseboard Assembly
NOTE
The I/O baseboard is lar
ge, so use care wh
en sliding
it into
the server chassis.
T
o replace the I/O baseboard assemb
ly
, perform the following steps:
172
174
Table of Contents
Default Chapter
2
Legal Notices
2
Table of Contents
3
1 About this Document
11
What's in this Document
11
Typographical Conventions
11
Related Documents
12
HP Encourages Your Comments
12
Where to Get Help
12
Information to Collect before You Contact Support
12
2 Controls, Ports, and Indicators
15
Introduction
15
Front Panel
16
Figure 2-1 Front View with Bezel
16
Figure 2-2 Accessing the Control Panel
16
Figure 2-3 Control Panel
17
Switch/Button and Front Control Panel LED Definitions
18
Additional Controls and Indicators
18
Hot-Plug Disk Drive Indicators
18
DVD-ROM/DVD-R/DVD-RW Drives
19
Quickfind Diagnostic Panel
19
Rear Panel
23
Figure 2-8 Rack Mount and Pedestal Rear View
24
Power Supply Status Leds
25
Figure 2-10 MP LAN Leds
26
Locator LED and Button
26
Management Processor LAN Leds
26
Gigabit Ethernet Card LAN Leds
27
3 External Connectors
29
Connector Pinouts
29
Universal Serial Bus (USB) Ports
29
VGA Port
30
Figure 3-3 Video Port Connector
30
Serial Ports
31
Management Processor LAN Port
31
Figure 3-4 Serial Port Connector
31
Figure 3-5 Management Processor Port
31
Additional Ports on Accessory Boards
32
Figure 3-6 LAN Port
32
Figure 3-7 SCSI Port, Ultra 3, 68-Pin
33
4 Installing Additional Components and Configuring
35
Installing Power Supplies and Disk Drives
35
Installing Hot-Swap Power Supply Units (PSU)
35
Figure 4-1 Front View
35
Figure 4-2 Hot-Swap Power Supply in P 0 Slot
37
Installing Hot-Plug Disk Drives
38
Figure 4-3 Metal Cover in Unused P 1 Slot
38
Installing Processors and Memory
40
Installing Processors
40
Figure 4-7 Removing the Processor Extender Board
42
Figure 4-8 Removing Processor Extender Board
43
Figure 4-9 Processor Cable Placed Correctly
44
Figure 4-10 Processor Cable Placed Incorrectly
44
Figure 4-11 Installing Processor on Extender Board Example
46
Installing Memory
47
Figure 4-12 16 DIMM Extender Board Minimum Configuration
50
Figure 4-13 32 DIMM Extender Board Minimum Configuration
50
Figure 4-14 Inserting DIMM into Extender Board Slot
52
Hot-Plug PCI-X
53
Hot-Plug PCI-X Operations
53
Operating System Support for Hot-Plug PCI-X Operations
53
PCI-X Hardware and Software Interfaces
54
PCI-X Slot Locations and Configurations
55
Hot-Plug Operation Procedures
58
Figure 4-16PCI-X OLX Divider Layout
60
Figure 4-17 Inserting PCI-X Card
61
Understanding Leds and Hardware Errors
63
Converting SCSI from Simplex to Duplex
65
Safety Information
65
Accessing the SCSI Backplane Board
65
Convert to Duplex
66
Figure 4-18Removing the SCSI Jumper Cable
66
Figure 4-19Installing the Duplex Board
67
Figure 4-20Installing SCSI Cable B to the SCSI Backplane
68
Figure 4-21Installing SCSI Cable B to the SCSI Adapter Board
69
Replacing the Removed Modules
70
Core I/O Connections
71
Management Processor (MP)
71
Accessing the Management Processor
72
Configuring Management Processor LAN Information
74
Figure 4-22The MP Main Menu
74
Management Processor Commands
75
Figure 4-23The LC Command Screen
75
Fibre Channel (FC) Boot Configuration
78
Booting the Server
85
5 Utilities
87
Extensible Firmware Interface (EFI) Boot Manager
87
Figure 5-1 EFI Boot Sequence
87
EFI Commands
88
EFI/POSSE Commands
91
Help
91
Baud
92
Help Configuration Command
92
Help Cpuconfig Command
92
Help Bch Command
92
Boottest
93
Cpuconfig
94
Default
95
Errdump
95
Info
96
Info Io Command
99
Info Boot Command
99
Lanaddress
100
Monarch
100
Pdt
101
Sysmode
101
Specifying SCSI Parameters
103
Using the SCSI Setup Utility
103
Management Processor
108
Accessing the Management Processor
108
Management Processor Command Interface
109
Figure 5-2 MP Welcome Screen
109
Management Processor Commands
110
Configure Serial Port Parameters
111
Reset BMC Passwords
111
Certificate Generate
112
Command Mode
112
Connect to Service Processor
112
Console
112
Console Log
112
Date
113
Default Configuration
113
Disconnect Remote or LAN Console
113
Display FRUID
113
Front Panel Process
113
Configure LAN Console
114
Display System ID
114
Help
114
Inactivity Timeout
114
MP Firmware Update
114
Configure Paging
115
LAN Status
115
Modem Reset
115
Modem Status
115
Power Control
115
Return to Main Menu
115
Create Local Session
116
Display Logs
116
Power Status
116
Reset BMC
116
Reset System
116
Set Access
116
Security Options
117
Firmware Revision Status
118
System Status
118
Tell
118
Transfer of Control
118
User Configuration
118
Virtual Front Panel
118
Who
118
Diagnostics
119
Exit from MP
119
Management Processor Help System
119
6 Troubleshooting
123
Troubleshooting Tips
123
Troubleshooting Methodology
123
Possible Problems
125
The System will Not Power-Up
125
The System will Not Boot
125
The System Has Intermittent Failures
126
The System LED or Diagnostic Leds Are Not on and no Error Messages Appear
126
Power Goes off on the Server and Does Not Come Back on
127
Troubleshooting Using LED Indicators
127
Front Control Panel Leds
128
Quickfind Diagnostic Panel Leds
129
I/O Baseboard LED Indicators
131
Troubleshooting Using Online Support Tools
132
Support Tools Manager
132
Event Monitoring Service
133
Instant Support Enterprise Edition (ISEE)
133
Troubleshooting Using Offline Support Tools
134
Offline Diagnostic Environment (ODE)
134
E-Diagtools
134
Figure 6-4 Offline Diagnostic Main Menu
134
Management Processor (MP) Event Logs
135
Other Event Logs and General Diagnostic Tools
136
Hypothetical Troubleshooting Scenario
137
7 Removing and Replacing Components
141
Safety Information
141
Service Tools Required
141
Accessing a Rack Mounted Server
141
Extend the Server from the Rack
141
Insert the Server into the Rack
142
Accessing a Pedestal Mounted Server
142
Figure 7-1 Accessing 25MM Torx Screws
142
Figure 7-2 Pedestal Mounted Hp Integrity Rx4640 Server
143
Front Bezel
144
Removing the Front Bezel
144
Replacing the Front Bezel
144
Figure 7-3 Removing and Replacing the Front Bezel
144
Front and Top Covers
145
Removing the Front Cover
145
Figure 7-4 Removing and Replacing the
145
Replacing the Front Cover
146
Removing the Top Cover
147
Figure 7-5 Removing and Replacing the Top Cover
147
Replacing the Top Cover
148
System Battery
149
Figure 7-6 Battery Location on I/O Baseboard
150
Memory Extender Board
151
Removing a Memory Extender Board
151
Figure 7-7 Memory Extender Board Latches
152
Replacing a Memory Extender Board
153
Figure 7-8 Memory Extender Board
153
System Memory Dimms
154
Removing System Memory Dimms
154
Installing Memory Dimms
154
Figure 7-9 16 DIMM Extender Board Slot Ids
158
Figure 7-10 32 DIMM Extender Board Slot Ids
158
Figure 7-11 Inserting DIMM into Extender Board Slot
159
Processor Extender Board
160
Removing the Processor Extender Board
160
Replacing the Processor Extender Board
161
Figure 7-12 Processor Extender Board
161
Processors
162
Installing Processors
162
Removing a Processor
162
Replacing a Processor
163
Figure 7-13 Processor Cable Placed Correctly
164
Figure 7-14 Processor Cable Placed Incorrectly
164
Figure 7-15. Installing Processor on Extender Board
166
Hot-Swap Chassis Fan Unit
167
Removing a Hot-Swap Chassis Fan Unit
168
Figure 7-16 Hot-Swap I/O Chassis Fans Removal and Replacement
168
Replacing a Hot-Swap Chassis Fan Unit
169
Figure 7-17 Hot-Swap Power Supply Chassis Fan Removal and Replacement
169
I/O Baseboard Assembly
171
Removing the I/O Baseboard Assembly
171
Figure 7-18 I/O Board Locking Lever
172
Replacing the I/O Baseboard Assembly
173
Figure 7-19 I/O Baseboard
173
Figure 7-20I/O Baseboard Select Switches
174
Hot-Plug PCI-X
176
Hot-Plug PCI-X Operations
176
Operating System Support for Hot-Plug PCI-X Operations
176
PCI-X Hardware and Software Interfaces
177
PCI-X Slot Locations and Configurations
178
Hot-Plug Operation Procedures
181
Figure 7-22PCI-X OLX Divider Layout
183
Figure 7-23 Inserting PCI-X Card
184
Understanding Leds and Hardware Errors
186
OLX Dividers
188
Figure 7-24 OLX Divider Removal and Replacement
189
Figure 7-25 OLX Divider Latch
190
Removing an OLX Divider
191
Replacing an OLX Divider
191
Voltage Regulator Modules (VRM)
192
Removing a Voltage Regulator Module (VRM)
193
Replacing a Voltage Regulator Module (VRM)
193
Figure 7-26 VRM Board Remove and Replace
193
Hot-Plug Disk Drives
195
Removing a Hot-Plug Disk Drive
195
Replacing a Hot-Plug Disk Drive
195
SCSI Backplane Board
198
Removing the SCSI Backplane
199
Figure 7-30 SCSI Backplane Removal and Replacement
199
Replacing the SCSI Backplane
200
Midplane Riser Board
201
Removing the Midplane Riser Board
201
Replacing the Midplane Riser Board
202
Figure 7-31 Midplane Riser Board
202
Hot-Swap Power Supplies
204
Power Supply Load Order
204
Removing a Hot-Swap Power Supply
204
Replacing a Hot-Swap Power Supply
205
Figure 7-32 Hot-Swap Power Supply Removal and Replacement
205
Power Distribution Board
206
Removing the Power Distribution Board
207
Replacing the Power Distribution Board
207
DVD Drive
208
Removing a DVD Drive
209
Replacing a DVD Drive
209
Figure 7-34 DVD Drive Removal and Replacement
209
DVD I/O Board
211
Removing a DVD I/O Board
212
Figure 7-35 DVD I/O Board Removal and Replacement
212
Replacing a DVD I/O Board
213
Display Board
214
Figure 7-36 Display Board Removal and Replacement
216
Removing the Display Board
217
Replacing the Display Board
217
Quickfind Diagnostic Board
218
Removing the Quickfind Diagnostic Board
219
Figure 7-37 Quickfind Diagnostic Board Removal and Replacement
219
Replacing the Quickfind Diagnostic Board
220
8 Parts Information
223
Field Replaceable Parts (FRU) List
223
9 Specifications
227
Introduction
227
Hardware Specifications
227
Dimensions and Weights
228
Server Component Dimensions
228
Index
231
Other manuals for HP Integrity rx4640
Service Guide
167 pages
Operation Guide
90 pages
User's & Service Guide
197 pages
Quick Start Guide
2 pages
Upgrade Guide
89 pages
5
Based on 1 rating
Ask a question
Give review
Questions and Answers:
Need help?
Do you have a question about the HP Integrity rx4640 and is the answer not in the manual?
Ask a question
HP Integrity rx4640 Specifications
General
Brand
HP
Model
Integrity rx4640
Category
Server
Language
English
Related product manuals
HP Integrity rx2660
249 pages
HP Integrity rx6600
348 pages
HP Integrity rx1620
136 pages
HP Integrity rx2620
216 pages
HP Integrity rx8640
45 pages
HP Integrity rx7640
101 pages
HP Integrity rx3600
11 pages
HP integrity rx2800 i4
156 pages
HP integrity rx2900 i4
156 pages
HP Integrity rx2800 - i2
151 pages
HP Integrity BL860c i4
163 pages
HP Integrity NonStop i NS2300
81 pages
To Next PageTo Next PageTo Previous PageTo Previous Page
Loading...
Need help?
General