General Maintenance 29
Hydraulic system Check oil level in tank,
and refill if necessary
X See page 276
Check if the shut-off
valve on the hydraulic
tank is open
X see Figure
5-27
Check ground for
overnight leaks
X
Check cylinders, pump,
control valve and
system for leaks. Repair
or replace if required
X See page 284
See page 261
See page 258
Replace hydraulic filter
a
Twice a
year
See page 282
Drain, flush, clean and
refill strainer
Twice a
year
See page 280
Check pressure X See page 288
Hopper area Clean traps on each side X See page 30
Tilt down the floating
panel and clean dirt
under or behind the
packer (if no arm is
installed)
X See page 40
Rollers, hydraulic
cylinders and cylinder
pins, hoses, pipes and
connections, wear of
floor surface and
hopper sides.
Visually inspect these
items
X
Body and chassis Check for corrosion X
Keep contact surfaces
clean between the body
and chassis
X
Cart tipper Grease and inspect all
pivots
X
Check pressure X
a. Also replace the return filter after the first 50 hours of operation.
Component/System Task Daily Weekly Monthly Yearly Page