THE NEW PIPER AIRCRAFT, INC.
PA-32-301FT / 301XTC
MAINTENANCE MANUAL
PAGE 4
Feb 19/04
1C22
5-20-00
4. Annual / 100 Hour Inspection
Procedure
A. Scheduled Maintenance (i.e. - paragraphs 5 and 6.)
(1) The required periodic inspection procedures are listed in paragraphs 5 (PA-32-301FT)
and 6 (PA-32-301XTC). These inspection procedures are broken down into major groups which
include Propeller, Engine, Cabin and Cockpit, Fuselage and Empennage,Wing, Landing Gear,
Operational Inspection and General. The first column in each group lists the inspection or
procedure to be performed. The second column is divided into two sub-columns indicating the
required inspection interval of 50 hours or 100 hours. Each inspection or operation is required
at each of the inspection intervals indicated by a circle (O). When vendor publications specify
times other than those designated in the the various columns, it will be indicated as:
or
in the inspection interval columns, or listed as a special inspection in 5-30-00, or both.
(2) Refer to the applicable chapter of this manual for instructions on how to gain access to remove
any item that must be removed and is not completely accessible.
(3) Inspection Report Forms.
To help in the performance of periodic inspections, Inspection Report forms are available
through Piper Dealers:
P/N 766-858 for the 6XT (S/N's 3255001 & up).
NOTE: Service centers conducting Part 91 Annual / 100 Hour Inspections can use the
Inspection Report Form (P/N 766-858), as a working check-off list, provided they
verify its currency against an up-to-date copy of the ICA (i.e. - this Maintenance
Manual, see 4-00-00 and 5-20-00).
(4) In addition to inspection intervals required in scheduled maintenance (i.e. - paragraphs 5
and 6), preflight inspection must also be performed.
(5) References to maintenance manual applicable areas are per the “chapter - system/sub-
system” assignment of subject material numbering system.
B. Special Inspections (see 5-30-00.)
C. Unscheduled Maintenance (see 5-50-00.)
As required by
“applicable vendor
publication”
See Note “X”
To Next Page
Loading...
Need help?
General