xi
Table of Contents Operator Manual 129390199
Section
Number Description Page
8 Routine Maintenance.....................................................................................................................8-1
8.1 Preventive Maintenance ........................................................................................................................ 8-1
8.2 Daily Maintenance ................................................................................................................................. 8-2
8.2.1 Replace Printer Paper Roll........................................................................................................... 8-2
8.3 Weekly Maintenance ............................................................................................................................. 8-4
8.3.1 Clean Chamber............................................................................................................................ 8-5
9 Troubleshooting ............................................................................................................................9-1
9.1 General .................................................................................................................................................. 9-1
9.1.1 Typical Alarm Screen................................................................................................................... 9-2
9.1.2 Typical Alarm Printout.................................................................................................................. 9-3
9.2 In-Cycle Alarms ..................................................................................................................................... 9-3
9.2.1 Too Long In Charge ..................................................................................................................... 9-3
9.2.2 Too Long In Exhaust.................................................................................................................... 9-4
9.2.3 Too Long In Evacuation ............................................................................................................... 9-5
9.2.4 Too Long In Air Break .................................................................................................................. 9-6
9.2.5 Under Sterilize Temperature........................................................................................................ 9-6
9.2.6 Over Sterilize Temperature.......................................................................................................... 9-7
9.2.7 OE/NOE Door Unsealed .............................................................................................................. 9-8
9.2.8 Chamber Pressure/Temperature Failure ..................................................................................... 9-9
9.2.9 Recorder Deviation Alarm............................................................................................................ 9-9
9.2.10Steam Utility Failure................................................................................................................... 9-10
9.2.11Water Utility Failure.................................................................................................................... 9-11
9.2.12Air Utility Failure......................................................................................................................... 9-11
9.3 Out-of-cycle Alarms ............................................................................................................................. 9-12
9.3.1 Too Long To Close OE (or NOE) Door ...................................................................................... 9-12
9.3.2 Too Long To Open OE (or NOE) Door....................................................................................... 9-13
9.3.3 Pressure In Chamber................................................................................................................. 9-13
9.3.4 Waste Temperature Probe Failure............................................................................................. 9-14
9.3.5 RTC Failure................................................................................................................................ 9-14
9.3.6 Emergency Stop Button Pressed............................................................................................... 9-15
9.3.7 Input/Output Fault – Module #X ................................................................................................. 9-15
9.4 Sensor Alarms ..................................................................................................................................... 9-16
9.4.1 Water In Chamber...................................................................................................................... 9-16
9.4.2 Too Long In Jacket Charge........................................................................................................ 9-17
9.4.3 Too Long To Seal OE/NOE Door...............................................................................................9-17
9.4.4 Too Long To Unseal OE/NOE Door........................................................................................... 9-18
9.4.5 Chamber Pressure Transducer Failure...................................................................................... 9-18
9.4.6 Chamber Temperature Probe Failure ........................................................................................ 9-19
9.4.7 Jacket Temperature Probe Failure............................................................................................. 9-19
9.4.8 OE/NOE Door Switch Failure..................................................................................................... 9-20
9.4.9 Recorder Temperature Probe Failure ........................................................................................ 9-20
To Next Page
Loading...
