HTA HT2000H - Page 163

To Next Page

To Previous Page

HT2000H_en_n.doc Page 167 of 167

DB9

pin #

Function

Note

1 N.C.

n.c.

2 TX

Transmission

3 RX

Receiving

4 DSR

Internally connected with DSR signal

5 DGND

6 DTR

Internally connected with DTR signal

7 CTS

8 RTS

9 N.C.

Main Page

Table of Contents3
Introduction4
Intended Use and Restrictions8
Symbol Table9
Warning10
Standards Compliance13
General Specification14
Functions Available Only through Hta Autosampler Manager14
Versions15
Description15
Options15
Pc Software Requirements (Hta Autosampler Manager )15
Technical Specifications16
Equipment Description20
Parts Definition20
HT2000H/HT2000HT Overview20
HT2100H Overview21
Syringe Location28
Connection Panel30
Moving Parts32
Tool Kit33
Touch Screen Display Description (Ht2000H/Ht2000Ht)34
Touchscreen Use34
Screen Templates35
Limited Warranty38
Installation39
Unpacking and Preliminary Operations39
Autosampler Assembly40
How to Lift and Carry the Autosampler43
Installation44
Autosampler Installation on the Mounting Plate44
Safety Lock Setting49
Electrical Connections50
Purge Line Connections51
Start-Up52
Pc Connection and Software Installation52
Autosampler Controlled by LAN-Connected PC53
Autosampler Connected Directly to the PC61
Accessories Installation62
External Pressure Regulator Installation63
Swagelok Adapter Installation65
System Integrity Tool Installation66
Preparing Sample Vial68
Vial Capping (Crimping Cap)69
Final Installation Operations70
Basic Training70
Set up Operations72
View Parameters72
Setup73
Setup: Alignment73
Setup: Syringe Warmer Assembly Installation76
Setup: Manual Operations85
Setup: Configuration88
Setup: Service94
Programming95
Ht2100H: Methods and Sequence95
Ht2000H/Ht2000Ht: Methods95
Method Menu95
Method X: Setting Method Parameters95
Method Tools99
Example99
Ht2000H/Ht2000Ht: Sequence101
Sequence Menu101
Setting Sequence Step Parameters101
Sequence Tools102
Ht2100H Operations103
Keys103
Keys Settings104
Status Indicators104
Reference Table104
Ht2000H/Ht2000Ht Operations107
Home Screen107
Home Screen: Standard User Interface107
Home Screen: Quick Start User Interface108
Single Injection108
Automatic Run109
Interrupting an Automatic Run110
Immediate Injection110
Skip Next Vial Option110
Syringe Purge111
Load and Unload Sample Vial111
Settings Menu111
Change Tray/Rack Type112
Eco Savings113
Troubleshooting115
Introduction115
Start up Errors116
Safety Lock Error116
Vial Locator Error116
Memory Error116
Method Errors117
Fill Volume/Pull up Strokes Settings Incompatibility117
Fill Volume/Syringe Pre-Fill Settings Incompatibility117
Touch Sensor Problems118
Falling Vials118
Obstacle Found119
Obstacle Found During Cover Movement119
Mismatch Errors120
Single Injection Mismatch Error120
Automatic Run Mismatch Errors120
Missing Errors122
Missing: Front Injector Alignment122
Missing: Rear Injector Alignment122
Missing: Touch & Plunger Zero122
Timeout Error123
Peripheral Communication Timeout123
Mechanical Errors123
Heating Errors124
Oven Error124
System Integrity Test Fail124
Damage to Syringe Needle125
Syringe Inspection126
Tray Emergency Release127
Tray Opening by Hand127
HTA Autosampler Manager" Troubleshooting129
Autosampler and PC Do Not Communicate (Connection by LAN)129
Analytical Troubleshooting131
Reproducibility Issue131
Peak Distortion or Tailing132
Carry over Issue132
Unexplained Chromatographic Peaks132
Retention Times Not Repeatable132
Faulty Temperature Read-Out133
Maintenance134
Ordinary Maintenance134
Cleaning of Vial Rack/Tray134
External Cleaning of Cabinet135
Incubation Oven Cleaning135
Touch Screen Display Cleaning136
Syringe Replacement in the Syringe Warmer Assembly136
Septum of the System Integrity Tool Replacement146
Preventive Maintenance Pack147
Extraordinary Maintenance147
Uninstalling and Disposal148
Autosampler Uninstalling148
Autosampler Shipping149
Autosampler Disposal152
Disposal Instructions152
Appendix A - Glossary154
Appendix B - Consumables156
Syringes156
How to Select the Correct Syringe Type (Only for HT2000HT)156
Sample Vials157
Vial Specifications157
Cap Specifications160
Septa Specifications160
Appendix C - Connection Panel161
Gc Connector161
Typical GC Interface162
RS232C Interface (Optional)162

HTA HT2000H - Page 163

Table of Contents

Related product manuals